2021 Acura TLX Type S power train problems

“While accelerating from a stop, I heard a loud bang from the drivetrain area and initially believed another vehicle had struck the rear of my car. After checking my surroundings, I realized there had been no collision. Immediately after the incident, the vehicle lost power delivery to the rear wheels. The vehicle is designed as an all-wheel-drive performance sedan, and the sudden loss of rear-wheel power significantly changed the way the vehicle handled. The vehicle became effectively front-wheel drive without warning, causing all engine power to be directed through the front wheels. This resulted in reduced traction, altered handling characteristics, and increased front tire wear. No warning lights, messages, or indicators appeared on the dashboard before or at the time of the failure. There were no symptoms that alerted me that a drivetrain failure was about to occur. The vehicle was inspected by an Acura dealership, and Acura confirmed failure of the transfer case and transmission components associated with the all-wheel-drive system. The transfer case and transmission are currently being replaced under the manufacturer's drivetrain warranty. I believe this…”

“The All Wheel Drive (AWD) system of the vehicle became partially inoperable after hearing a loud bang under normal vehicle acceleration some time in early 2025. The vehicle did not trigger or display any warnings stored in the onboard computer or on the dash display that the AWD system had any faults or issues. Had this system failed during an emergency situation involving hazardous or dangerous driving conditions like snow, ice, heavy rain, it could have caused me to not have improved capable vehicle handling. The vehicle's ability to distribute power evenly to all 4 wheels was hindered and operating as front wheel drive only after the loud noise was observed. Additionally, transmission gear oil began leaking underneath the vehicle around the transmission casing. The issue has been reproduced, confirmed, and validated by technicians of a local Acura dealership. The dealership was approved to completely replace the following two components of the AWD system under the manufacturer's 6 year / 60K mileage powertrain warranty: 1. Transmission 2. Transfer case - also known as power transfer unit or PTU”

“The transfer case in my Acura TLX Type S failed due to the internal splines stripping at approximately 57,600 miles. I heard a loud bang while attempting to maneuver out of a parking spot that was covered in snow. When this occurred, the transfer case was no longer able to transfer power to the rear wheels, causing the all-wheel-drive system to stop functioning. As a result, the vehicle effectively operated as front-wheel drive only. The most concerning part of this failure is that the vehicle provided no warning whatsoever to the driver. There were no dashboard alerts, drivetrain warnings, AWD system warnings, or check engine lights indicating that the AWD system had failed. The vehicle continued to operate and display information as if everything was functioning normally. This occurred during the winter in New York while driving in snowy conditions, where the AWD system is critical for traction and safety. Because there was no warning that the AWD system had failed, I continued driving the vehicle assuming it still had AWD capability. On multiple occasions the vehicle became stuck in snow due to the loss of rear-wheel power. A critical drivetrain component…”

“This 2021 Acura TLX Type-S has experienced a complete failure of the transfer case after approximately 40,000 miles of use. This unfortunately is a known issue on the online forums for this vehicle in model years 2021-2023. I have a video inspection performed by the local dealership proving this. The only warning is a one-time loud boom when accelerating and a leaking from the transfer case of fluid thereafter. There is no safety issue best I can tell, however the car only performs in front drive mode once the transfer case quits working. The issue is due to weak splines within the transfer case that shear off and thus damage the 10-speed automatic transmission in the process. Acura has a 6 year 70,000 mile warranty, so a complete replacement is covered, however my concern is for whether the new transfer case part # 29000-5YK-060 which replaces the old 29000-5YK-050 part will do the same. This is a very expensive fix into the 5 figures (over $10,000) and really needs to have a recall as there are dozens and dozens of owners online who have experienced this failure.”

“Was driving the car under normal acceleration when the transfer case failed. No power to the rear wheels. Acura dealer confirmed the problem. Will be fixed under warranty. No warning lamps or messages on the dash.”

“While driving my 2021 Acura TLX Type S, I began losing traction frequently during normal daily driving, especially when turning corners or accelerating from a stop sign or stop light. At first, I believed the issue was related to my tires, so I replaced them, but the same problem continued. After researching online, I discovered that transfer case failures are a known issue on these vehicles, affecting both new and used models. Currently, my vehicle is at the dealership, but they were unaware of this recurring transfer case problem and have no information about it. This is concerning because the failure of the transfer case directly affects traction and stability, creating a potential safety risk to myself and others on the road. It appears to be a systemic issue that Honda/Acura has not yet acknowledged.”