2016 Audi A3 air bags problems

“My 2016 Audi A3 (VIN [XXX]) underwent Safety Recall 69BY on XXX, to correct a defect in the front passenger occupant detection system (PODS), including replacement of the occupant detection sensor. Less than two years later, the same safety-system malfunction returned. The vehicle intermittently displays "Safety system: system fault," "Audi pre sense: system fault," and "Passenger airbag off." These warnings appear unpredictably and sometimes clear temporarily before returning. This malfunction creates a serious safety risk because the vehicle may fail to recognize a front-seat passenger and disable the passenger airbag during a collision. We cannot safely use the front passenger seat. On XXX, at 74,151 miles, Audi Marin diagnosed the malfunction and documented fault codes B102202, B102229, and B12251B. The dealership confirmed that diagnostic testing continued to indicate a faulty passenger occupant sensor (G128) and recommended replacement. Audi Marin's service manager informed us that Audi has redesigned the replacement component, but the updated part is on an extended backorder from [XXX]. The dealership cannot currently complete the repair. Audi of America…”

“The contact owns a 2016 Audi A3. The contact stated that the front passenger’s side air bag occupant sensor failed to identify a passenger seat in the seat. A dealer was contacted. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that PODS had failed and needed to be replaced. Additionally, the engine was consuming an excessive amount of engine oil. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 19V474000 (AIR BAGS); however, the VIN was not included in the recall. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 44,000.”

“The contact owns a 2016 Audi A3. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer who diagnosed that the front passenger’s seat air bag sensor had failed and needed to be replaced. The vehicle was repaired under NHTSA Campaign Number: 21V198000 (Air Bags). The air bag warning was illuminated approximately one and a half years later. The vehicle was returned to the dealer who informed the contact that the repair was no longer covered under warranty. The vehicle had not been repaired. The manufacturer was made aware of the failure and a claim was opened. The failure mileage was approximately 67,000.”

“The contact owns a 2016 Audi A3 Cabriolet. The contact stated that upon starting the vehicle, the air bag warning light illuminated. The vehicle was previously taken to the local dealer, where it was repaired under NHTSA Campaign Number: 21V198000 (Air Bags). The vehicle was taken to the local dealer, Audi Richmond (12592 Broad St., Richmond, VA 23233), where it was determined that the module connected to the sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 35,000.”

“PODS system recall was fixed, but not properly, 3 months after it was "fixed" the passenger airbag is off warning comes on beeping loud and turns off and back on constantly. Super annoying and dealership won't do anything without paying a huge fee.”

“I've been told by the dealer that a fix for the PODS system recall is still not available. This is after almost a year and a half of the issue being known. My car is now regularly illuminating the airbag light and beeping for the passenger to put the seat belt on even if no one is using the seat. This is becoming very annoying and I'm told there is no way to fix this.”