2011 BMW 3 Series fuel/propulsion system problems

“Dealership performed VANOS bolt replacement recall on 2011 BMW 328i. Vehicle has 63K miles and is otherwise in excellent condition. Post recall, vehicle experiences unstable idle with rpm dipping low when stopped in gear during initial engine warm up period. Issue stabilizes somewhat but not completely gone once engine is at operating temperature. This is a safety issue with engine surging, hesitating, and potentially stalling when stopped at stoplight or intersections.”

“Fuel Pump Control Module and Fuel Pump Failed at highway speeds. There was a notification warning for a failed fuel pump and then the engine shut down and stalled at highway speeds within seconds.”

“Fuel sending unit has broken and began to expel fuel out upwards within the rear bottom of the back seat were the sending unit is located. The plastic that ensembles the gas sending unit itself cracks over a certain period amount of time and causes gasoline to spray in that area. Gas has began to accumulate outside the gas tank right above the sending unit part, which causes harmful and incredibly strong gasoline odor inside the car and outside the car, predominantly on the back seat of the driver area. Very dangerous for even a small amount of fire to be near it. The problem cause a harmful and overwhelming amount of dangerous gasoline fumes to tolerate breathing near that area or the car itself.”

“i was driving to work and the car stalled in the middle of traffic when i slowed the vehicle down, the idle is rough and all over the place, car is very hesitant to accelerate and vibrates or shakes when approaching any speed. then the check engine light popped on and is still on, i’ve parked the car since the incident to do some research on what the cause could be.”

“Last Saturday, I was driving to New Jersey. I drove from Brooklyn through the Holland Tunnel with no issues. However, after driving about 4 or 5 miles on the New Jersey Turnpike the fuel pump malfunction light came on and the car started to slow down then jerk. Thankfully, I was able to pull off to the side since vehicles travel at a very high speed on the New Jersey Turnpike. After I pulled off to the side the engine stopped and would not restart. I was able to get a tow to the nearest BMW — BMW of Bloomfield. They took my keys and ran my VIN. The service manager from that location advised me that they could fix the fuel pump for me at no cost because it is a known issue and is covered under code SULEV. However, I would have to leave my car there for the weekend. Since I live in Brooklyn, I decided to get another tow to BMW of Manhattan where my car has been since Saturday. I did not receive a call from the service advisor until Monday evening, to whom I explained everything that I just wrote. He told me that there were no open recalls on my vehicle and he would let me know the cost to replace the fuel pump. I explained to him that the service manager at BMW…”

“My Vehicle has been on Recall since March 2, 2022. There are increasing problems and an occasional smoke and burning smell. This is effecting me getting an inspection and registering my vehicle.”