2021 BMW X5 M electrical system problems

“The alternator terminal post overheated and broke off. The terminal post from the alternator broke off inside the middle of the cable eyelet and had welded itself to the end of the power cable. The cable showed signs of being overheated and melted. The power cable was loose and dangling next to the alternator creating a serious fire risk while driving. When this issue occurred I got a vague message indicating a power related failure and then BMW Roadside immediately called my vehicle asking me to pull over or take it to a service center. I immediately took it to the shop that services my vehicle and they documented the issue and informed me of the safety recall that mentions this specific issue. This is the exact problem related to NHTSA Recall 20V-761 though BMW has told me that my specific VIN is not covered. I also understand that this recall has been extended additional porduction dates more than once. I believe my vehicle is an example of later production models built in 2021 that are still at risk for this issue and should also be recalled.”

“My 2021 BMW X5 xDrive40i intermittently fails to start, occurring on approximately 80% of start attempts, and displays the message "Repeat Start Attempt." This has been confirmed by code reading to be a starter-related malfunction. This defect significantly affects vehicle reliability and raises a potential safety concern. BMW previously recalled vehicles equipped with similar starter motors due to starter solenoid defects that could cause overheating, electrical short circuits, and an increased risk of vehicle fire. The symptoms on my vehicle appear consistent with those associated with the previously identified defect. I respectfully request that NHTSA investigate whether the starter motor defect previously addressed through BMW recalls extends beyond the identified production range, including 2021 model year vehicles. The recurring failure, similarity to previously recalled defects, and potential fire hazard warrants further review.”

“My 2021 BMW X5 xDrive40i Sport (112,000 miles) intermittently fails to start, occurring on approximately 80% of start attempts, and displays the message "Repeat Start Attempt." The issue first occurred on September 8, 2026, while the vehicle was parked at my residence and was confirmed by BMW Roadshow Memphis on September 11, 2026, as a starter-related malfunction. The dealer quoted more than 1,600 to replace the starter motor because the vehicle is outside the warranty period. This defect significantly affects vehicle reliability and raises a potential safety concern. BMW previously recalled vehicles equipped with similar starter motors due to starter solenoid defects that could cause overheating, electrical short circuits, and an increased risk of vehicle fire. The symptoms on my vehicle appear consistent with those associated with the previously identified defect. Publicly available recall information indicates BMW's corrective action included software modifications intended to reduce current flow through the starter system. However, this appears to be a mitigation measure rather than a correction of the underlying hardware defect. I contacted BMW North…”

“The starter motor malfunctioned, which then prevented the car from starting when it was hot. It could only be started after it had completely cooled down. Additionally, the fault code indicated that there was a problem with the starter motor. I also noticed that there was a similar recall before, so I'm wondering if this one might also pose a risk of fire.”

“The contact owns a 2021 BMW X5. The contact stated that the AC was inoperable. The vehicle was taken to a dealer and an independent mechanic on several occasions to repair the AC; however, the failure reoccurred after each repair. The AC was not replaced. The contact believed that the issue was caused by Hybrid system.”

“Vehicle: 2021 BMW X5 xDrive40i (G05) Mileage: 54,423 miles Component: Central Information Display (CID)/ MGU (Media Graphics Unit) Head Unit Safety Defect: The CID intermittently goes completely blank without warning. When this occurs, the backup camera is unavailable, creating a safety hazard when reversing. Navigation, radio, Apple CarPlay, and vehicle settings are also unavailable. Failure History/Diagnosis: The first failure occurred about one month ago while I was reversing. After several hard resets and leaving the vehicle unused for two days, the display began working again. The failure occurred again yesterday when my spouse started the vehicle. I took it to Bobby Rahal BMW of South Hills, PA. The BMW technician confirmed that the head unit (MGU) and RAM (Receiver Audio Module) are not communicating. The technician also found corrosion on the head-unit power connector and inside the head unit, suggesting moisture intrusion and/or an internal electrical short. The dealer recommended replacing the head unit, with the part costing over $4,000, plus labor and additional diagnosis to identify the source of the leak/moisture causing the corrosion. Inspection:…”