1997 Chevrolet Astro service brakes, hydraulic problems

“TL* THE CONTACT OWNS A 1997 CHEVROLET ASTRO MINIVAN. THE CONTACT WAS DRIVING AT VERY LOW SPEEDS WHEN THE ANTI BRAKE SYSTEM FAILED, CAUSING INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS. THE CONTACT STATED THAT THE FAILURE WAS SIMILAR TO NHTSA CAMPAIGN NUMBER ID: 05V379000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK) BUT THE CONTACT WAS ADVISED BY THE DEALER THAT HIS VEHICLE AS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 346,000.”

“HIGHWAY TRAFFIC SUDDENLY SLOWED DUE TO AN ACCIDENT AHEAD. THE STEEL BRAKE LINE TO THE REAR BRAKES FAILED DUE TO EXCESSIVE RUST DURING AN EMERGENCY STOP ON HIGHWAY. THE FRONT BRAKES WERE ABLE TO SAFELY STOP THE VEHICLE WITH NO CONTACT WITH ANY OTHER VEHICLES. STEERING WAS ALSO VERY DIFFICULT DURING THE STOP POSSIBLY DUE TO ABS ACTION, BUT NO WHEEL LOCK EVER OCCURRED. *TR”

“TL*THE CONTACT OWNS A 1997 CHEVROLET ASTRO. THE CONTACT STATED THAT THE ABS WORKS INTERMITTENTLY WHILE DRIVING APPROXIMATELY 10 MPH. WHEN APPROACHING A STOP, THE BRAKES WOULD NOT APPLY AND SHE ALMOST REAR ENDED ANOTHER VEHICLE. THIS HAS BEEN A PERSISTENT FAILURE EVER SINCE SHE PURCHASED THE VEHICLE. THE DEALER REPAIRED THE BRAKES AT THE COST OF $125, BUT THE FAILURE PERSISTS. THE DEALER STATED THAT THERE WAS NO BRAKE FAILURE. THE CONTACT STATED THAT IN ORDER FOR THE BRAKES TO WORK, SHE HAS TO SLAM HER FOOT ON THE BRAKE PEDAL, BUT THIS SOLUTION IS NOT ALWAYS GUARANTEED. THE CURRENT MILEAGE WAS 50,800 AND THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 01-10-08. *KB THE CONSUMER STATED GROSSMAN CHEVROLET REPAIRED THE CHEVY VAN AGAIN ON NOV. 30, 2007 AT THE COST OF $979. THE CONSUMER FURTHER STATED IN 2005 SHE REAR ENDED A VEHICLE AT 5MPH BECAUSE VEHICLE WOULD NOT STOP WHILE APPLYING THE BRAKES. THE DEALER STATED RIGHT FRONT HUB ASSEMBLY WAS REPLACED, REPAIRED FRONT COVER GASKET, REPLACED FRONT PINION, AND REPLACED SERPENTINE BELT. UPDATED 12/31/07 *TR”

“ANTI-LOCK BRAKE FAILURE AS DESCRIBED IN RECENT ARTICLES FOR GM MODEL YEAR 2000 AND LATER. NEAR COLLISIONS WITH VEHICLES AND PROPERTY AT LOW SPEEDS. PROBLEM IS STILL NOT CORRECTED, ANTI-LOCK BRAKE SYSTEM TEMPORARILY DISABLED TO MAKE VEHICLE SAFE TO DRIVE.”

“BRAKE PROBLEMS ON 1997 CHEVROLET ASTRO VAN. *MR THE CONSUMER STATED THAT MORE BRAKE WORK WAS NEEDED. THE BRAKES HAD RUSTED AND NEEDED TO BE TURNED, THE A/C WAS NOT BLOWING COLD AND THERE WAS A HEATING CONCERN. *SC THE REAR AXLE SEALS AND DIFFERENTIAL GASKETS WERE LEAKING.. *JB”

“LTR FM JAMS M. CLARK (MD) RE THE DEFECTIVE 4L60 ELECTRONICALLY CONTROLLED 4 SPEED TRANSMISSION W/OVERDRIVE IN HIS 1997 CHEVROLET FULL SIZE CONVERSION VAN, REPLY IN DUPLICATE ATTN DENISE NOOE/ANNAPOLIS OFC. *PH THE CONSUMER ALSO HAD A FULL BRAKE REPLACEMENT PERFORMED ON THE VEHICLE. *JB (1997 CHEVROLET FULL SIZE CONVERSION VAN)”