1998 Chevrolet Astro service brakes, hydraulic problems

“TL*THE CONTACT OWNS A 1998 CHEVROLET ASTRO. THE CONTACT STATED THAT THERE WAS NOT ENOUGH SPACE BETWEEN THE BRAKE PEDAL AND THE MOTOR COVER FOR HIM TO MANEUVER HIS FEET. HE WAS CONCERNED THAT HE COULD POSSIBLY GET HIS FOOT CAUGHT BETWEEN THE BRAKE PEDAL AND MOTOR COVER IN THE EVENT THAT HE NEEDED TO APPLY THE BRAKES QUICKLY. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 114,000. UPDATED 04-20-09 *BF UPDATED 04/24/09.*JB”

“TL*THE CONTACT OWNS A 1998 CHEVROLET ASTRO. WHILE DRIVING 10 MPH THE ANTILOCK BRAKE SYSTEM ACTIVATED AND THE CONTACT HAD TO SWERVE TO AVOID STRIKING ANOTHER VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING WHEN BRAKING AT LOW SPEEDS. THE MANUFACTURER STATED THAT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL AND WILL NOT PAY FOR THE REPAIR. THE CURRENT MILEAGE IS 88,000, AND FAILURE MILEAGE WAS 85,000*AK.”

“DT*: THE CONTACT STATED WHILE DEPRESSING THE BRAKE PEDAL AT LOW SPEEDS, THE PEDAL WAS HARDER TO DEPRESS AND HAD A LONGER STOPPING DISTANCE. THE DEALER WAS NOT CONTACTED.”

“WHILE SLOWING TO A STOP AT ABOUT 2 MPH ON DRY PAVEMENT, THE VEHICLE'S ANTI-LOCK BRAKING SYSTEM STARTED RAPIDLY CYCLING, NO BRAKES WERE GRABBING BECAUSE OF THE RAPID CYCLING, THE ENGINE STARTED TO RACE SLIGHTLY, AND THE VEHICLE WAS HEADED FOR EITHER TWO PEDESTRIANS OR A BUILDING. TO STOP THE VEHICLE, I PLACED THE TRANSMISSION IN REVERSE AND THE VEHICLE CAME TO A STOP. AFTER ANOTHER BRAKE ATTEMPT THE BRAKES RESPONDED. I WENT TO AN ISOLATED STREET WITH SOME ICE AND DRY PAVEMENT, AND THIS ANTI-LOCK BRAKING FAILURE OCCURRED IN 1 OUT OF 5 BRAKING ATTEMPTS. I NEVER RECEIVED AN ANTI-LOCK WARNING LIGHT AND THE SYSTEM COMPLETED ITS SELF TESTS PROPERLY ON EACH ENGINE START UP. I REMOVED THE 60 AMP FUSE TO DISABLE THE SYSTEM AND I AM NOT SURE I CAN EVER TRUST THIS SYSTEM AGAIN. *JB”

“WHILE BRAKING AT LOW SPEED THE ABS WOULD CAUSE EXTENDED STOPPING DISTANCE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK FRONT WHEEL SPEED SENSOR REPLACED. LEFT FRONT WINDOW HANGS WHEN GOING UP. WINDOW TRACKE LUBED. PADS AND ROTORS REPLACED. RER BRAKE ADJUSTED. BRAKE PEDAL KICKED UP WHEN ALMOST TO A STOP. REPLACED BRAKE CALIPERS/ROTORS/ BACKING PLATES AND REMOVED SENSORS AND CLEANED RUST BUILD UP ON SENSOR AND HUB ASSEMBLIES. BOTH IDLER AMRS AND FRONT AND REAR SHOCKS WERE REPLACED DUE TO FRONT END PLAY. *TT”

“VEHICLE TENDS TO CONTINUE TO HAVE PROBLEMS WITH THE STEERING EVEN AFTER THE STEERING COMPUTER CHIP WAS REPLACED. VEHICLE SWERVES UNEXPECTEDLY WHILE BEING DRIVEN AT ABOUT 50-55 MPH. *AK THE STEERING VEARED TO THE LEFT OR THE RIGHT. BRAKE POWER BOOSTER PUMP WENT OUT LEAVING THE VEHICLE BRAKELESS. *TC”