2017 Chevrolet Bolt steering problems

“The steering wheel fails to return to center after turning and will stay stuck in the turned position. In looking through forums, it appears to be a common issue for Bolts that Chevrolet has not taken accountability for as no recall has been issued even though the complaints are quite numerous with the steering gear needing to be replaced, even at low mileage.”

“The steering (rack and pinion) is dangerous. My previous 2019 bolt with 43000 miles handled great and this one (17 with 36xxx) I have to keep both hands on the wheel at all times because it pulls after a turn and the wheel doesn’t find center so I am constantly sawing at the steering wheel. At highway speeds this could become dangerous and cause an accident from an overcorrection. Steering has become stiff and almost like I have a bad alignment but it could go in either direction. I already had a near miss at highway speeds due to the steering not being as responsive as I know it should be. I feel like the vehicle could lose control if I am a fraction of a second late in my steering. I’m not sure if this was planned obsolescence but I feel like the steering should last at least another 60,000 miles before I have to make any major repairs.”

“The steering rack is binding and has malfunctioned. The steering wheel does not return to center after turning and vibrates or wobbles while driving, which may impair steering control and makes the vehicle unsafe to drive. The problem was diagnosed and confirmed by a certified automotive repair shop. No warning lights or messages appeared. The only prior symptom was progressively worsening steering-wheel operation over time.”

“I am reporting a potential steering system safety defect involving my 2017 Chevrolet Bolt EV. The problem began at approximately 22,800 miles. The steering wheel developed a grinding noise, a noticeable catching/binding sensation when turned, and would not return to center normally after a turn. The condition could be felt even while the vehicle was stationary and not running by turning the steering wheel back and forth. While driving, I could feel the steering pull and catch when turning left or right. The problem gradually became worse over about two months. There were no warning lights or dashboard messages. I first tried to have the vehicle inspected by a Chevrolet dealership, but that appointment was canceled. I then took it to Lee Johnson Chevrolet in Kirkland, WA. At 23,661 miles, the dealer test drove the vehicle and documented that they verified my concern. Their diagnosis stated that the steering gear had “internal worn gear damage” and required replacement of the steering gear/rack assembly. The intermediate steering shaft bolt was also involved in the repair. I paid $4,406.56 for the repair which includes a separate $301.24 diagnostic charge. The…”

“The steering rack on the Chevrolet Bolt EV does not return to center on turns. Over the course of the past 25k miles, my particular model has slowly began to lock up on deep turns. This occurs on sharp rights, lefts, and on both on and off ramps - especially the ones that loop around. The steering rack gets stuck on sharper turns and continuous turns, requiring force to return back to center or to get out of the turn. With hands off the wheel, the vehicle maintains its turn radius and without driver input, would inevitably turn into a barrier, object, or even another vehicle. Issues began around the 80k mark, possibly sooner, and dealer did not fully disclose this occurrence. The steering binding is a safety issue, and if left long enough might fully bind up causing an accident. It reduces my ability to sense road traction conditions and make fine adjustments.”

“COMPONENT: Electric power steering (EPS) steering gear / rack and pinion assembly. WHAT HAPPENED: The steering gear binds internally. After a turn the wheel does not return to center and must be forced back to straight; steering feel is stiff and clunky. On at least one occasion the wheel felt stuck in place partway through a turn and I had to fight it to finish the maneuver. I nearly lost control of the vehicle. Exact date, location and speed of that incident: UNKNOWN. The condition is chronic and has worsened over time. I own two Bolt EVs (2017's); both have this defect and I am filing a separate complaint for each. Mileage on this vehicle: approx 96,000 but it's been bad since 80,000 (at the very least). SAFETY RISK: Binding steering requires manual correction after every turn, increasing risk of overcorrection, unintended lane departure and delayed emergency response. Worst at intersections, on/off ramps and parking lots. The driver cannot anticipate when the wheel will stick. WARNING LAMPS / PRIOR SYMPTOMS: [No warning lamps, messages or codes appeared] Earliest symptom: [stiff or notchy steering]. First noticed [right away when I bought the car used].…”