2018 Chevrolet Bolt steering problems

“Steering has resistance and will not to return to center/neutral position without driver manipulation. I've never experienced this probelm with another car and See many other Chevrolet Bolt owners have experienced the same problem. IT definitely seems to be a design and /or assembly flaw. Local GM dealer service department insists it's an isolated issue. Very costly repair required.”

“The steering rack loses its lubrication make it turn harder and could potentially fail completely leading to a loss of steering. I noticed that when I am steering around a curve the steering wheel fails to pull back to the center position and has to be manually forced back. Loss of steering or steering malfunction could lead to a fatal crash. I have not had my vehicle inspected by a dealer or mechanic but have researched the problem and many people online have reported failure of the steering rack/gear as well. There is no warning from the manufacturer about this problem and could go unnoticed until the problem is severe. The manufacturer (Chevrolet) should be required to replace this faulty part at no charge to the customer.”

“Sometimes, the steering wheel of the car will not return back to center after turning. The steering also feels a lot heavier. This usually happens after driving straight for a little and then having to make a turn, but may happen spontaneously in other situations as well. The steering wheel suddenly not returning to center when it is expected increases the chances of accidents, especially in areas with many curves and people/activities. The car does not show any warning signs. The dealership said they said they didn't notice it when driving and thus didn't want to further check it (they only drove it from one parking spot to another).”

“On 4/5/2025 I was driving at 35mph and the steering wheel began to violently shimmy. The vehicle became difficult to steer putting safety at risk. Slowed to 25mph but shimmy did not stop. ABS warning light came on and Stabilitrak warning light came on and warning that steering was being was being automatically reduced. Driving became very difficult. Stopped and had car towed to Chevrolet. Car was diagnosed with broken left and right front axle anticlick washers and metallic debri found on sensors. Both front axle anticlick washers were replaced, sensors cleaned, and codes cleared, and brake fluid had to be flushed. Cost $850 to repair. Subsequently found out another friend had same thing happen to their 2018 Bolt. This was a safety issue and put us at risk while driving.”

“The steering of my 2018 Chevy Bolt is sticky. At moderate speeds and going around sweeping corners and curves, the steering becomes sticky and does not want to return to center - you must guide steering back to center and there is friction involved in pulling it back to center. This is a safety issue because the sticking does not allow the driver to sense true road conditions especially in adverse weather. The problem has been reproduced by the dealer and is commonly discussed in Chevy Bolt forums including this one: [XXX] There are no warning lights or indicators of this issue - it is something that you begin to feel with the steering. Certain weather, temperature, and driving conditions seem to make it more pronounced.”

“Well known steering issue causing steering to almost "lock" and not return to center. Seemingly caused by lack of grease on the steering gear. Obviously dangerous for all involved as it is a steering problem.”