2016 Chevrolet Corvette wheels problems

“Overview: Beginning sometime in 2020, the coating of the rearview inside mirror began to degrade and lose its reflective capability. By [XXX] visibility through the mirror was so bad that I had to have it replaced by the local Chevy dealership. Because it was out of warranty, I had to pay $453.93 out of pocket. The vehicle was unsafe to drive due to the mirror's degraded condition. 1. What component or system failed or malfunctioned, and is it available for inspection upon request? Rearview interior mirror 2. How was your safety or the safety of others put at risk? I could not see clearly in the rearview mirror. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Many other drivers have reported the same issue with this model on the Corvette forum (see [XXX] ) Also, Sunrise Chevrolet in Collierville, TN confirmed the mirror was defective and replaced it at my expense. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No”

“Overview - November 2022, my 2016 Covette Stingray vibrated badly at highway speeds, that I took it into the Sunrise Chevrolet Buick GMC dealership in Collierville, TN to investigate the cause. They made videos showing 3 of the 4 wheels (not tires) were warped. This is my second car (rarely driven), so I was quite surprised. Chevy was out of stock and the vehicle was out of warranty, so I had to replace all 4 wheels using after-market parts that had to be shipped to the dealership at total cost of $3,400.58. A few weeks after the wheels were replaced, I noticed the vibration was still occurring at highway speeds, so I returned it to the same dealership on Jan 3rd, 2023. The dealership said that the transmission fluid had to be replaced with a "new design" to prevent the shaking at my expense for a total of $1,066.10. The problem is so well-known, that it's called the "Chevy Shake" on the Corvette forum. I feel that Chevrolet has put my safety at risk twice in 2022 with a faulty mirror (I files a separate complaint for that), the faulty tires, and the faulty transmission fluid.”

“The contact owns a 2016 Chevrolet Corvette. The contact stated that the wheels were cracking from the inside. The contact stated that the TPMS warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the wheels needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was not contacted. The failure mileage was approximately 20,000.”

“Started loosing tire pressure on L/R tire, local tire shop informed and showed me that my left rear rim has a crack which causes loos of air. This is a known issue that GM wants to blame on drivers but issue stems from GM using cheaper cast aluminum materials instead of forged materials which are better suited due to the amount of torque that the ZO6 models generated. *Note* GM used forged material on their ZR1 models!!”

“Vehicle has less than 8k miles and right rear wheel has a stress fracture on inside of wheel. Zero signs of damage to the tire or anything indicating cause of fracture was from a road hazard. Fracture causes a slow air leak. Hundreds if not 1000s of corvette owners 2015-2019 have had this issue.”

“Rear rims (20 by 12, cast aluminum) have both cracked with no trauma to the rim other than simply driving the car on the street. Right rear has been repaired multiple times and has now cracked right beside the repaired cracks. The left rear has cracked on the inside by the bead and with two wheels cracked and leaking air, I have ended up ordering two new rims from GM. I put some tire sealant in the left rear and that slowed down the slow leak while the new rims were being delivered. I have talked about this many times with the dealer and with GM, and they say I must have caused the cracks by my driving, which doesn't make sense to me. They say sue me and point out that you, the NTHSA, haven't ordered the rims recalled. These are now the seventh and eighth cracks that have developed on my rear rims, three different rims. One original lasted 27,000 miles before the first crack. The replacement original for that first rim lasted about 7,000 miles before the first crack. The last original rim of the same size on the back lasted 37,500 miles before the first crack appeared. I bought a 1978 Corvette new with forged aluminum rims and drove it some 150,000 miles with…”