2017 Chevrolet Corvette wheels problems

“I went to the Chevy Dealer for service and to investigate a tire that keeps losing air. The dealership advised that the 2 rear wheels both have cracks that are consistent with a known problem in this model vehicle. They also documented that the two front wheels have bends also associated with a known defect in this model vehicle.”

“Multiple Wheels (9) have been replaced and multiple tires. Have had to repair each of these wheels upwards of 20+ times and it’s not allowed legally after 3 cracks per wheel. Safety issue as tires would blow out or go flat in short time. Yes, been inspected multiple times by dealers, GM and told not covered under any warranty. One incident, GM agreed to replace the 2 rear wheels at 50% retail!”

“Cracked (chrome) wheels on 2017 Corvette Grand Sport at 30228 miles. The tire icon appeared on the driver information display. Passenger side rear tire. After inflating the tire I took it to my dealer, Jorns Chevrolet where I purchased it brand new. Jorns is a leading Corvette dealer in Wisconsin. The dealer actually had a set of after market replacement wheels on display in the showroom. The technician removed the wheel and pointed out a large crack causing the slow leak. Not wanting to pay an exorbitant amount for one wheel and gamble on the other three I decided to replace all four with forged aftermarket wheels. Now, the technician discovered a crack in the driver side rear wheel also. Jorns explained that they have replaced wheels, with similar problems, on forty other Corvettes! Appealing to GM was a futile waste of time. GM skillfully crafted a policy to claim any sort of compensation virtually impossible. Initial contact requires the owner to deal with some appointed law firm and comply with their front line screening. IF you succeed with that, mountains of documentation are required. Very disappointing considering, the frequency of failures and owners…”

“Noticed one wheel kept leaking down slowly. After a couple of weeks of filling the air in the tires, it was down near the warning pressure again on one rear wheel. Decided to remove the wheel to inspect the cause of the leak. Upon removal of the wheel, there were two noticeable cracks on the inner bead diameter of the wheel. I know this has been a big issue for all the C7 GS corvettes, because this is my 4th C7 GS with the same issue. All my previous C7 GS have had all the factory rear wheels to crack. I don't understand why there has not been a recall since every C7 GS I've owned had this same issue on all the rear wheels. I typically do my own repairs unless they are covered under warrant. I have worked on automobiles for over 35 years in my personal garage and it has become an expectation that any C7 GS or Z06 with a rear tire leaking is caused by a cracked wheel. Have contacted Rick Hendrick City Chevrolet in Charlotte NC about the cracked wheel before deciding repair method that will be taken.”

“Cracks found on 3 of 4 wheels when the wheels were off for cleaning. Cracks are on 2 front wheels and 1 rear. Cracks are located on the inner edge of the barrel, and extend up the edge, then about 0.5 to 1.0in toward the centerline of the wheel. Further cracking could cause loss of air pressure.”

“my car is constantly having issues with hard shift in the transmission. also the wheels on this car is not structure properly. if you drive the car hire a speed there's a chance will could crack”