2000 Chevrolet Malibu service brakes, hydraulic problems

“I PURCHASED MY 2000 CHEVY MALIBU IN MARCH OF 2001. IN EARLY 2003 I TOOK MY CAR IN FOR REPAIRS BECAUSE I HAD LOST STEERING ABILITY. I WAS TOLD THE SUB FRAME NEEDED TO BE REPLACED SO I HAD IT DONE. A WEEK LATER I HAD TO BRING THE CAR BACK TO THE DEALERSHIP FOR BRAKE PROBLEMS. I WAS THEN TOLD THE ABS NEEDED TO BE REPLACED SO I HAD THAT DONE. SINCE THEN I HAVE HAD TO CHANGE MY BRAKES NUMEROUS TIMES. JUST LAST YEAR I HAD TO REPLACE THE PADS 3 TIMES IN A 9 MONTH PERIOD BECAUSE THE PADS HAD BEEN WORN ALL THE WAY DOWN. DURING THAT 9 MONTH PERIOD I ALSO HAD TO REPLACE THE CALIPERS AND ROTORS ONCE THEN A WEEK LATER THE ROTORS HAD TO BE RESURFACE AGAIN. NOW I AM HAVING TO HAVE MY BRAKE PADS REPLACED AGAIN THIS WEEKEND. SO THAT MAKES A TOTAL OF 4 BRAKE PAD CHANGES IN LESS THAN A YEARS TIME. *TR”

“TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHEN THE TURN SIGNALS WERE ACTIVATED, THE CONTACT WOULD HEAR A SOUND AND THE SIGNALS WOULD STOP WORKING. THE VEHICLE WAS DRIVEN TO A LOCAL REPAIR SHOP APPROXIMATELY TWO WEEKS LATER AND THE MECHANIC STATED THAT THE SIGNALS WERE WORKING PROPERLY AND NO FAILURE COULD BE FOUND. IMMEDIATELY AFTER LEAVING THE REPAIR SHOP, THE TURN SIGNALS FAILED TO WORK AGAIN. SHE RETURNED THE VEHICLE TO THE REPAIR SHOP AND WAS INFORMED THAT THE VEHICLE HAD A DEFECTIVE SWITCH, WHICH WAS RELATED TO NHTSA CAMPAIGN ID NUMBER 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). THE DEALER AND MANUFACTURER STATED THAT HER VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CURRENT AND FAILURE MILEAGES WERE UNAVAILABLE. UPDATED 10/16/08 *BF THE ABS LIGHT HAD ILLUMINATED. A NEW LEFT FRONT HUB ASSEMBLY WAS INSTALLED. UPDATED 10/21/08. *JB”

“2006 CHEVROLET MALIBU. CONSUMER COMPLAINT ON LEMON LAW. CONSUMER BELIEVES HIS VEHICLE FALLS UNDER THE LEMON LAW SPECIFICATIONS. *KB THE CONSUMER STATED THE DEFECTIVE CALIPER DESIGN CAUSED PREMATURE WEAR OF THE CALIPERS AND ROTORS. AFTER REPLACING THE FACTORY SUPPLIED CALIPERS, THE PREMATURE ROTOR AND BRAKE PAD WEAR CEASED. THE INTAKE MANIFOLD WAS REPLACED SEVERAL TIMES. ONCE THE NEW GASKET MATERIAL WAS IMPLEMENTED THE INTAKE GASKET NO LONGER LEAKED. THE SAFETY HAZARD LIGHT CONTROL ASSEMBLY ON THE STEERING WAS REPLACED THREE TIMES BECAUSE THE DEALER REPLACED DEFECTIVE COMPONENTS WITH ADDITIONAL DEFECTIVE COMPONENTS IT WAS FINALLY DETERMINED THE HAZARD LIGHT SWITCH WAS COVERED UNDER A SPECIAL AGREEMENT WITH NHTSA, HOWEVER, GM REFUSED TO HONOR THE AGREEMENT. *JB”

“INTAKE MANIFOLD GASKET REPLACED THREE TIMES UNDER AND OUTSIDE OF WARRANTY. HAZARD SWITCH MALFUNCTIONING - ALMOST CAUSED ACCIDENT TURNING SIGNAL/WIPER WASHER SWITCH MALFUNCTIONING PREMATURE BRAKE WEAR UNTIL CALIPERS REPLACED CHECK ENGINE LIGHT VARIOUS EMISSIONS AND FUEL VAPOR LEAKS. *JB”

“2000 CHEVROLET MALIBU SEDAN WITH RUSTED LEFT AND RIGHT BRACKETS THAT ARE WELDED TO THE K FRAME AND HOLD THE STEERING ARM**CC THE CONSUMER HAD PERSISTENT PROBLEMS WITH THE BRAKES. *JB”

“I HAVE A 2000 CHEVY MALIBU. AS MANY MALIBU OWNERS MY CAR HAS THE SAME ISSUES. BLOWER FAN DOESN'T WORK ON SETTING 1 AND 2, REAR SPEAKERS DON'T WORK IN COLD WEATHER, REAR TAIL LIGHTS DON'T ALWAYS WORK, WEIRD BRAKING ISSUES IN THE COLD, AND AIR CIRCULATION BUTTON CHANGES FROM CLOSED TO OPEN AUTOMATICALLY. THESE ARE JUST SOME ELECTRICAL ISSUES WITH THE CAR AND I THINK I FOUND THE ROOT CAUSE. THE WINDSHIELD RUBBER SEAL ON MY CAR WAS UNATTACHED FROM THE WINDOW OUTSIDE AT THE BOTTOM ON THE PASSENGER SIDE. I FOUND OUT BECAUSE AFTER A HEAVY RAIN A LOT OF WATER WAS SHOWING ON THE FLOOR OF THE PASSENGER SIDE. THE WATER DAMAGES HAS BEEN HAPPENING FOR YEARS. I FOUND WATER SITTING IN THE PLASTIC MOLDING RIGHT UNDER THE BLOWER FAN. WATER CORRODING THE ELECTRICAL CABLES ON THE FLOOR. WATER TRACKS OVER THE COMPUTER BOARD LOCATED UNDER THE GLOVE BOX. I'VE INFORMED CHEVROLET AND ASK FOR THEM TO CREATE A TSB BUT THEY DENIED MY REQUEST.*JB”