2018 Chevrolet Malibu service brakes problems

“I was driving in town through a stoplight when I noticed my brakes stopped working. Also when I had stopped the car still in drive and the car had shut off completely in the middle of the road and was not able to turn back on. The car would keep trying start but none were successful. My car also stated that there was reduced power to the engine and the car would hesitate to gain speed as well. My safety and others were put to risk because my brakes stopped working so I could’ve caused an accident. When we trying to find what was wrong with it through a code reader we had noticed the piece had shattered inside of the engine. No insurance, police or manufacturer has inspected the issue.”

“I own a 2018 Chevy Malibu. At approximately 57,000 miles, the original engine experienced a vacuum pump failure that resulted in catastrophic engine damage. The engine was replaced by General Motors under the vehicle's warranty. I then drove the vehicle for approximately another 52,000 miles with the warranty replacement engine. At that point, I experienced a sudden loss of braking while driving. My vehicle was again diagnosed with a vacuum pump failure, and the vacuum pump was replaced. Approximately one week after the vacuum pump replacement, the warranty replacement engine suffered catastrophic failure. The repair facility diagnosed cylinder #3 scoring and informed me that the engine required replacement. I was told that the engine failure was related to the vacuum pump failure. Because the warranty replacement engine was no longer covered under warranty, General Motors initially declined to cover the repair. Initially, neither General Motors nor the Chevrolet dealership was willing to accept responsibility for the issue. After continued discussions, General Motors ultimately agreed to provide partial financial assistance as a goodwill adjustment. However, I…”

“While coming down McClure pass in Colorado my brakes failed. The the car went to engine power reduced mode. After getting the car to an independent mechanic I was told that the vacuum pump failed and exploded the parts into the camshaft. After 2 days of repairs I was finally able to get my car back to working order. This could have been a fatal car accident coming down a mountain pass. I was able to get stopped safely because I know the road. I had just driven 700 miles over Eisenhower Pass, Vail Pass, Glenwood Canyon, and then the final pass being McClure pass where it failed. I bought this car brand new and I probably won't buy another Chevy after this. This was a terrifying experience that I will have lasting trauma from.”

“The Vacuum pump continues to go out causes code P1101. I have replaced it 4 times and people just in my town are fighting this code for dear life like me! It causes our brakes to barely work and make it completely unsafe to drive as the check engine light goes in and out for MAF sensor. It’s not safe. It needs to be recalled. It doesn’t matter if i buy the most cheapest part or expensive part. It has happened on multiple occasions where i replace it and within 2 months, its back on and does reduced power in the middle of me driving on busy roads. i’ve been almost hit and almost caused multiple accidents because I have to pull over.”

“The brake booster unit, vacuum pump , brake light switch failed and malfunctioned and it is available. My safety and others on the road was at risk due to brakes being stiff and hard as a brick. Possibly nearly hit an other vehicles on the road. No warning lamps or other symptoms prior to the failure.”

“After diagnostic troubleshooting from DTCs on a check engine light, it was discovered that the brake vacuum pump connected to the engine was completely nonfunctional. Previous symptoms included stiff brake, loss of brake power at random brake periods which could have cause and accident with other drivers, and finally malfunctioning sensors attributed to the exhaust system. This also led the vehicle to be unable to pass state regulated Emissions testing because of the inability to maintain proper emissions levels. Brake Vacuum pump that was removed from vehicle to inspect and diagnose is still available for inspection. Recent findings show that Chevrolet/GM is aware of the issue in their vehicles but refuses to address or replace faulty brake vacuum pumps. It is a common problem amongst 2013-2022 Chevrolet Malibus. Vehicle that is in question was inspected by a certified mechanic shop with failed emissions test. Solid check engine light appeared once the brake had become harder to push and stop the car. OBD scans show DTC codes that were pertaining to MAF and MAP malfunctions in readouts and communications to the ECM. After further inspection, the ABS module had…”