2018 Chevrolet Silverado 1500 suspension problems

“I was driving on the highway at about 70 mph and the passenger side lower control arm where the ball joint sits broke. It messed up the passenger fender and tire along with the steering link. It also bent the upper control arm as well. The ball joints were replaced about 6 months ago.”

“Vehicle was determined to be unsafe to operate per inspection performed by Mike Maroone Chevrolet on 8/26/24 immediately after I purchased from Rocky Mountain Auto Brokers in Colorado Springs on 8/8/26. It was discovered by customer immediately after sale that bank 2 catalytic converter was restricted internally (after Rocky Mountain failed to correctly diagnose and repair 3 times before and after purchase). Customer discovered emissions warranty extension and took to Maroone Chevrolet. After warranty repair inspection of vehicle determined it was not safe for customer to pick up and drive vehicle and generated a report and video showing front suspension damage so loose that could cause crash and vehicle was towed back to Rocky Mountain for repairs. Rocky Mountain has failed to provide any documentation on these repairs and many subsequent repairs including transmission replacement after many written requests. Customer cannot verify if vehicle repairs brought vehicle back to a safe condition. Almost anll repairs by Rocky Mountain has failed resulting in missing bolts, bolts falling out after transmission replacement As well as failure of many CV Axel…”

“The frame of my 2018 Chevrolet Silverado 1500 has rusted through to the point of failing Maine state safety inspection at only 41,000 miles. A licensed Maine inspection station identified structural frame corrosion and determined the vehicle is unsafe to operate. A Chevrolet dealer confirmed the frame rust and stated the truck must have rusted sections cut out and welded to be made roadworthy. The vehicle is available for inspection upon request. Safety risk: A rusted-through frame on a pickup truck is a serious structural defect. Frame failure while driving could cause loss of vehicle control, separation of suspension or drivetrain components, or catastrophic structural collapse, particularly at highway speeds or under load. The vehicle is currently unregisterable in Maine due to this safety failure. The failure has been confirmed by both an independent licensed inspection station and by a Chevrolet dealership service department. This failure is consistent with a known manufacturing defect documented in GM Technical Service Bulletin 19-NA-255, which acknowledges that the wax coating applied to the frames of 2011–2024 Silverado and Sierra trucks was improperly…”

“The contact owns a 2018 Chevrolet Silverado 1500. The contact stated that while driving at undisclosed speeds, the vehicle started shaking abnormally. No warning lights were illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 60,000.”

“We bought the truck new 2018 and started having trans issues and leaf springs popping. So, we took back to dealership and all they did was change fluid in trans and pump grease in-between leaf springs. I did get them to finally change passenger side leaf spring out, but that does no good when leaf spring they put on has the same issue. The leaf springs have to much gap in between each leaf. I told them to give me a 1,000.00 and I would go and have some made. That way, if I put a load on leaf spring it less chance they could break going down the road. Also, we have issues with radio that also did not get fixed by gm and still has the issue we can't use today. My truck also has the 6.2l engine that you guys have had complaints on. I will tell you that I'm not happy with what Gm is doing with these defected parts on these trucks. They are doing quick fixes to save them money on their screw ups and could get us killed. We are still having the issues to this day and they just brush us off. We pay a lot of money for these truck and Gm is ripping us off and costing us more money because we have to pay to fix their mistake, they should be fixing for free. All I want…”

“Both upper control arms have broken off at the ball joints. Also the cam and Lifters are failing and this vehicle has been maintained in accordance with the manufacturer guidelines.”