2017 Chrysler Pacifica Plug-in Hybrid electrical system problems

“The car's lithium batteries caught fire to the point of smoldering. This happened at the end of the charge cycle. The car was parked in our garage and if the fire department did not come to help, the fire could have intensified and burned down our whole house. We are very thankful we caught it so quickly. No warnings or issues were apparent with the vehicle when it was parked and put on the charger.”

“What component or system failed or malfunctioned, and is it available for inspection upon request? - Internal charging system or vehicle battery pack malfunctioned & caught fire. Vehicle is available for inspection now, but not sure about when it is removed from our property. How was your safety or the safety of others put at risk? - It was a big fire! Close to structures, vehicles & dry foliage – super lucky it didn't spread. Smoke was very noxious and affected our entire neighborhood. Neighbors have reported respiratory irritation since the fire. I now have a cough, burning throat and headaches. Has the problem been reproduced or confirmed by a dealer or independent service center? - There's a burned out van at the end of my driveway... specific instance of this problem does not need confirmation Similar issues are reported on the internet. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - Not yet. Chrysler says it'll take 2-3 days for issue to be "escalated". Insurance is sending someone. Fire department HazMat crew verified that the battery pack is now "cold" but toxic chemicals are a public…”

“The vehicle's high voltage battery was being charged using a Siemens VG2 EVSE when an arcing sound was noticed and burning smell and smoking was seen. Looking back at our home energy monitor, it appears to have been arcing for close to an hour without any warnings being thrown until shortly after being noticed. The car did eventually show a charging system error, but the charging didn't stop until I physically unplugged it. The L1 pin on the vehicle and the EVSE showed scorch marks and damage from the arcing, but thankfully it was caught before a fire happened.”

“We had the FCA Recall #Z11, NHTSA Recall #22V-077 repaired on this vehicle. One week later, the plug-in hybrid Pacifica was parked in the garage, plugged in but done charging. In the middle of the night, the battery spontaneously combusted. We heard a loud boom sound and found the car smoldering and emitting significant amounts of smoke. The car then burst into flames. The fire department soaked the car with water but it continued to reignite for approximately two hours despite the fire department’s best efforts to extinguish the fire. The car was completely destroyed. It also caused significant chemical smoke damage to our garage and home. As soon as we found it smoking, we rolled it out of the garage, which saved our house from catching on fire. Luckily our children were not in or next to the car at the time the battery combusted. There were no warning signs in the car prior to this incident. The vehicle has been inspected by insurance and is available for further inspection. At least two members of the family experienced adverse health consequences following the smoke exposure.”

“The contact owns a 2017 Chrysler Pacifica Hybrid. The contact stated that after starting the vehicle, the parking brake inadvertently engaged and the passenger's and driver's side rear sliding doors were unable to unlock. The contact disconnected the battery to correct the failure. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 66,000.”

“Risk of Fire and no information forthcoming as to remedy. Recall was first advised in February. If the vehicle is defective then it either needs to be fixed or bought back by the manufacturer. If it isn’t then retract the recall. Do something.”