2007 Chrysler Pacifica engine problems

“Engine Sub Frame-AKA Engine Cradle is rotting out. Vehicle was inspected on July 6, 2023 at Jim Rielh's Chrysler -Jeep Dealership located at 32899 Van Dyke, Warren Michigan 48093. The report came back as " FOUND FRONT ENGINE CRADLE / FRAME ROTTED / RUSTED OUT." This vehicle has been well maintained and has been Safety Inspected by the same dealership in 2021 & 2022 and never advised there was a problem with the Engine Cradle. Now in 2021, three engine mounts were replaced to correct clunking noises when accelerating, but again there was never an advisement of a potential Engine Cradle Rot. The vehicle had 127, 640 miles on it when it was inspected by the dealer. The results were reported to Chrysler Customer Care via email and by phone but no response as of today.”

“The engine cradle as well as the engine mounts along with the subframe have deteriorated uncommonly fast resulting in the vehicle involuntarily swerving into other lanes of traffic”

“I am requesting that NHTSA issue a recall for the known defect and serious safety hazard for the 2007 Chrysler Pacifica. These vehicles need to be recalled effective immediately and removed from our highways. The engine cradle rot poses a a risk for accidents and the manufacturer is privy to these problems and had legal action taken against them for a similar notification of different years. The 2007 models should be recalled as well. Please issue the recall and do the right thing. Who knows, you may save someone’s life who is unaware of the dangerous equipment they are driving. Not to mention the manufacturer needs to either to buy back the vehicles, pay for the costly repairs and or compensate the owners who are unable to drive their vehicle or are forced to purchase another vehicle because Chrysler and those in authority have failed and refused to act with integrity and take action to make the recall. There are countless consumers who complain of the same problems of cradle rot, but nothing has been done. Please note the following:l, which lists the court case and consumer complaints: https://www.casemine.com/judgement/us/59145d2dadd7b049341f482e…”

“After fueling, especially if the take is full. The engine will die several times in the first 5 or more miles driven. Of course, this also means no power steering. You may be turning at an intersection, on a freeway or just traveling on a surface street. Still, you are without power and no power steering putting the car and occupants in danger. Usually, putting the car in neutral and starting gets you going again, at least until the next event. We have had as many a 5 such events on a 4.5 mile drive home form the gas station. This has now progressed. The last fill up, the nozzle cut of several times and restart over and over to finally fill the take. We knew it could take more fuel, Ultimately it took on 15 Gallons. This time, even after the second day and about 20 miles on the car it will still die at random, especially at idle, say at a stop light. Also with this phenomenon, when the gas gouge gets to just below a half of a tank reading, it may suddenly drop to (E) empty. This is not a good feeling, even though we know it is a bogus reading. The gauge may or may not read correctly at about a half tank the next time the car is started, after an overnight rest.…”

“Several Times while driving and often when turning at a slow speed the Pacifica stalls. This is a common problem with no help from Chrysler. No codes come up and several mechanics and dealers have tried to fix the problem to no avail and at a lot of expense. In checking this problem out on the internet, many, many people have complained about this problem because it is highly dangerous and puts peoples lives at risk! Why doesn't Chrysler investigate and find the reason and provide a fix or why won't the NHTSA look into this problem. It also is known to happen to 2005 and 2006 Pacificas.”

“WHILE DRIVING ON INTERSTATE RT 80 I EXPERIENCED A LOUD NOISE AND SMOKE AND FLAMES WERE COMING FROM THE ENGINE. PULLED OVER AND GOT MYSELF AND MY GRANDDAUGHTER OUT OF HER CAR SEAT. THE ENGINE CONTINUED TO BURN UNTIL THE FIRE DEPT COME. *TR”