2001 Chrysler PT Cruiser exterior lighting problems

“TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE FOG LIGHT WARNING INDICATOR ILLUMINATED AND SMOKE APPEARED FROM THE STEERING COLUMN. THE CONTACT WAS ABLE TO PULL THE VEHICLE OFF THE ROADWAY, TURN OFF THE ENGINE, AND RESTART THE VEHICLE. THE CONTACT SMELLED BURNING WIRES, BUT THERE WERE NO FLAMES. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT FOUND A RECALL FOR THE FOG LIGHTS ONLINE, BUT WAS UNABLE TO PROVIDE FURTHER INFORMATION. THE FAILURE MILEAGE WAS UNKNOWN.”

“WAS DRIVING DAUGHTER TO WORK AND BEGAN TO SMELL A BURNING ODOR. HOWEVER, I ASSUMED IT WAS A PASSING VEHICLE (STREETS WERE VERY WELL LIT, AND I WOULD NOT HAVE NOTICED MY LIGHTS WERE OUT). THE NEXT MORNING MY WIFE WAS HEADING OUT TO PICK-UP OUR DAUGHTER FROM WORK, AND WAS FLASHED BY THE LOCAL POLICE FOR NOT HAVING LIGHTS ON. THROUGH THE PROCESS OF ELIMINATION I DECIDED TO REPLACE THE MULTIFUNCTION SWITCH. WHEN I RECEIVED THE SWITCH AND ATTEMPTED TO INSTALL IT I NOTICED THAT THE WIRING HARNESS WAS SLIGHTLY MELTED. UPON INVESTIGATING THE INTERNET FOR A HARNESS I CAME UPON SEVERAL WEBSITES WITH NUMEROUS COMPLAINTS INVOLVING THE SAME PROBLEM. (IF EVERYONE WERE TO UNITE AND POST THEIR COMPLAINTS HERE THERE WOULD BE MANY) THESE PROBLEMS SEEM TO BE RELATED TO A SHORTING OUT OF THE WIRING CAUSED BY THE OEM FOG LIGHTS. THIS HOWEVER, DID NOT CAUSE EITHER THE DASH FUSE OR THE ENGINE COMPARTMENT FUSE TO BLOW, WHICH IS A REAL CONCERN. *TR”

“FOG LIGHTS MALFUNCTION VERY FREQUENTLY. FOR THE PAST COUPLE OF MONTHS, VEHICLE'S BATTERY HAS BEEN DRAINED BECAUSE THE FOG LIGHTS ARE ON (WHICH ARE NEVER TURNED ON OR EVEN USED) AND WILL NOT GO OFF. HAPPENS FREQUENTLY AND IT'S DIFFICULT TO GET THE FOG LIGHTS TO GO OFF, THE LIGHTS CONTROL HAS TO BE JIGGLED JUST RIGHT TO GET THEM TO GO OFF SO WE KNOW THE BATTERY WON'T BE DRAINED AFTER A FEW HOURS. LATELY, IT HAS GOTTEN HARDER AND HARDER TO GET THEM TO TURN OFF AND FINALLY HAD TO PULL THE FUSE IN ORDER TO MAKE THEM GO OFF. *TR”

“I BOUGHT A 2001 PT CRUISER AND WITHIN A COUPLE OF WEEKS THE HEADLIGHTS STOPPED WORKING. REPLACED MULTI FUNCTION SWITCH BUT DID NOT HELP. HAD TO RE-WIRE THE LIGHTS TO MAKE THEM WORK. ALSO IT SOUNDS LIKE THE PASSENGER SIDE FRONT TIRE HAS SOMETHING LOOSE. POSSIBLY BUSHINGS?? I'VE SEEN SEVERAL COMPLAINTS ABOUT THE LIGHTS. WHAT IS IT GONNA TAKE TO GET A RECALL IN PLACE? WE GOT A TICKET FOR IT. *TR”

“VEHICLE WAS USED TO DRIVE TO LOCAL STORE AT NIGHT. FOG LIGHTS WERE NOT TURNED ON AT ANY TIME. I PARKED IN DEPARTMENT STORE PARKING LOT AND CAME OUT AFTER SHOPPING FOR ABOUT 45 MINUTES AND NOTICED A BURNING SMELL COMING FROM PT CRUISER. OPENED THE DRIVERS DOOR AND ODOR BECAME MORE APPARENT. NOTICED SMOKE ROLLING OUT OF STEERING COLUMN. ALSO NOTICED FOG LAMP INDICATOR ON DASHBOARD WAS ON. HOWEVER, ALL LIGHTS AND SWITCHES WERE OFF. I HAD TO PULL OUT SEVERAL FUSES UNTIL I FOUND THE ONE RELATED TO THE FOG LAMPS. THAT WAS THE ONLY WAY TO QUICKLY POWER OFF THE FOG LAMPS AND STOP THE SMOLDERING. THIS IS A POTENTIAL FIRE HAZARD! *TR”

“WEB SITE TOPIX WILL CONFIRM THE INCREDIBLE # OF FOLKS THAT HAVE HAD FOG LAMPS TURN ON AFTER CAR IS SHUT DOWN CAUSING BATTERY DRAIN. 100'S HAVE PAID FOR REPLACEMENT PART MULTI-FUNCTION SWITCH. THIS CONTROLS FOG, HEAD, ACCESSORY, & DASH LIGHTING. TO PREVENT THE FOG LAMPS FROM COMING ON BY THEMSELVES, MOST HAVE REMOVED FUSE # 8 TO REMOVE THE FOG LAMPS FROM THE CIRCUIT. PEOPLE REPORT SMOKE COMING FROM TURN SIGNAL LEVER, & THE COMPLETE LOSS OF ALL LIGHTING IS QUITE COMMON. I PERSONALLY HAVE REPLACED THE MULTI-FUNCTION SWITCH 3 TIMES ON MY WIFE'S 2001 P.T. CRUISER WITH ONLY 50,000 TOTAL MILES & SHE BEING ORIGINAL OWNER. BY PARKING HER CAR MINUS FUSE # 8, NOT USING DOME LIGHTING, & ALWAYS PARKING WITH THE SIGNAL LEVER IN THE DOWN OR LEFT TURN POSITION HAS PREVENTED THE MYSTERY FOG LAMP ISSUE, & KEPT HER BATTERY FUNCTIONING. THIS "TEMP" SOLUTION HAS ALLOWED HER ABOUT 6 OR 8 MONTHS OF DRIVING W/O THE PROBLEMS OTHER PT OWNERS STRUGGLE WITH. SOONER OR LATER SOMEONE WILL LOSE LIGHTING OR A FIRE WILL OCCUR INSIDE THE STEERING WHEEL WHICH WILL CAUSE SERIOUS INJURY, LOSS OF VEHICLE & POSSIBLY DEATH. CHRYSLER DENIES ANY KNOWLEDGE, BUT WANTS MORE THAN $1,000.000 TO ANALYZE &…”