1996 Chrysler Sebring suspension problems

“1996 CHRYSLER SEBRING COUPE. CONSUMER WRITES REGARDING CHRYSLER EMPLOYEE LUNCH BREAK ACTIVITIES *TGW THE CONSUMER STATED HE EXPERIENCED MECHANICAL FAILURE WHILE DRIVING 20 MPH. THE LEFT FRONT BALL JOINT SUDDENLY SEPARATED AND JAMMED THE TIRE UP INTO THE FENDER WELL AT AN AWKWARD ANGLE. THE CONSUMER STATED IT COST OVER $800 TO REPLACE THE SUSPENSION PARTS ON BOTH SIDES. THE CONSUMER STATED THE REASON FOR THE FAILURE, WAS DUE TO LACK OF LUBRICATION, BECAUSE YEARS AGO, MANUFACTURERS CHOSE TO DELETE THE INEXPENSIVE GREASE FITTING ON SUSPENSION PARTS AND INSTEAD CHOSE SUBSTITUTED SEALED BALL JOINTS THAT WERE SUBJECT TO FAILURE. *JB UPDATED 04/26/11.”

“RECALL #750 FRONT LOWER CONTROL ARM BALL JOINT ALLEGED REPAIRED 02-10-98. THIS IS A NEW (10-08-09) RECALL. DUE TO MY VEHICLE WAS AT THE DEALER, IT WAS ASKED IF THE NUMBERS OF THE BALL JOINTS AND CONTROL ARMS NUMBERS COULD BE CHECKED TO SEE IF ORIGINAL CHRYSLER OR AFTERMARKET QUALITY PARTS WERE USED. THOUGH THIS IS A SERIOUS SAFETY ISSUE, LOSS OF STEERING, THE SERVICE ADVISOR ADVISED I'D NEED TO CHECK THE ORIGINAL REPAIR ORDER (02-10-98). THE ORIGINAL OWNER IS DECEASED. SO I GUESS I SHOULD CRAWL UNDER THE CAR AND LOOK FOR WHEREVER THESE PARTS ARE, LET ALONE THE NUMBERS, OR PAY SOMEONE ELSE TO CHECK THEM, OR JUST HOPE CHRYSLER HAD AND USED THEIR OWN PARTS. *TR”

“LOWER LATERAL ARM BROKE ON OUR 1996 CHRYSLER SEBRING. DEALER AND CHRYSLER HAVE REFUSED TO FIX THE CAR UNDER RECALL. THIS IS THE 3RD MAJOR FAILURE AND INCONVENIENCE OF THIS PART. THE LAST FAILURE WAS 8 MOTHS AGO. THERE IS CLEARLY A SAFETY ISSUE HERE AS WELL AS A MECHANICAL DEFECT. *JB”

“DT*: THE CONTACT STATED WHILE DRIVING 65 MPH, THE FRONT END OF THE VEHICLE SHOOK, WHICH CAUSED A LOSS OF VEHICLE CONTROL. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, WHO DETERMINED THAT THE RUBBER ON THE FRONT LOWER BALL JOINTS HAD SPLIT. THERE WAS A NHTSA RECALL # 99V066003 WHICH PERTAINED TO THE LOWER BALL JOINT. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.”

“DT*: THE CONTACT STATED WHILE DRIVING 15 MPH THE FRONT RIGHT TIRE FLIPPED SIDEWAYS, THE FRONT DRIVE SHAFT SHEERED OFF THE OIL FILTER AND KNOCKED IT FROM THE MANIFOLD. THIS OCCURRED ON AN ICY ROAD DURING NORMAL BRAKING WITHOUT WARNING. THE VEHICLE WAS PULLED TO THE CONTACTS HOME. THE DEALERSHIP AND MANUFACTURER WAS NOTIFIED HOWEVER, NO REPAIRS HAVE BEEN MADE.”

“DT: JUNE 30 2005 THE LEFT FRONT BALL JOINT BROKE WHILE DRIVING. THE CONSUMER WAS DRIVING 35 MPH. THERE WAS A NOISE, SPARKS WERE FLYING, AND THE CONSUMER LOST STEERING CONTROL AND BOUNCED OFF A CURVE. THERE WERE NO WARNING LIGHTS ON THE VEHICLE. THE VEHICLE WAS RECENTLY INSPECTED IN MAY AND NO PROBLEMS WERE REPORTED. THERE WAS A RECALL, BUT THE CONSUMER WAS NOT AWARE OF IT. THE CONSUMER NOTICED THERE WAS A CORROSION PROBLEM WITH THE BALL JOINT. THE CONSUMER DIDN'T HAVE THE RECALL NUMBER. THE VEHICLE IS NOW HAVING REPAIR WORK DONE. CHRYSLER IS WILLING TO PAY THE REPAIRS. THE BEARINGS HAD TO BE REPLACED, THE LEFT FRONT WHEEL BEARING WAS REPLACED TWICE. *JB”