35 owner complaints to NHTSA about the 1998 Chrysler Sebring cite suspension, 11% of all 319 complaints for this model year. NHTSA also lists 3 recalls on this component.
“TL* THE CONTACT OWNS A 1998 CHRYSLER SEBRING. WHILE DRIVING APPROXIMATELY 20 MPH, THE FRONT DRIVER SIDE TIRE DETACHED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE LOWER BALL JOINT AND AXLE FAILED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE LOWER ARM CONTROL, LOWER BALL JOINT, TIE ROD, AND AXLE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. THE VIN WAS NOT AVAILABLE.”
“HISTORY OF FAILED ATTEMPTS OF DEALER [ WHITTEN BROTHERS,RICHMOND,VA ] TO DIAGNOSIS THIS PROBLEM AND CORRECT IT. PROBLEM IS A HARSH NOISE COMING FROM THE FRONT[UNDER ]THE CAR WHEN A ROAD POT HOLE OR IMPERFECTION [SUBSTANTIAL ] IS RUN OVER. THE NOISE IS PRONOUNCED , INDICATING SOME TYPE OF DEFECT MUST BE PRESENT.. THE LAST TIME I WAS THERE AT WHITTEN BROS THE RECALL WHICH WOULD HAVE CORRECTED THIS WAS NOT ISSUED YET... RECALL ANNOUNCED BELOW ..I WAS NEVER NOTIFIED ,,I AM THE ORIGINAL OWNER AND SHOULD HAVE BEEN RECALLED... RECALLED ANNOUNCED 12/27/2010 NHTSA REFERENCE # 10E059000 NUMBER AFFECTED : 22,689 SUSPENSION : FRONT : CONTROL ARM : LOWER ARM FEDERAL-MOGUL : RECALLED REPLACEMENT CONTROL ARM ASSEMBLIES PARTS #. K7425 , 10945 , FA4510X...AND K7427 , 10946 , FA4611X NOTE : THESE PARTS CAN FAIL CAUSING THE BALL STUD TO WEAR THRU THE CONTROL ARM HOUSING RESULTING IN NOISE AND OR SEPARATION OF THE BALL STUD FROM THE CONTROL ARM HOUSING.. RESULTING IN THE DRIVER LOOSING STEERING CONTROL..CAR CAN CRASH .AT ANY SPEED. FEDERAL-MOGUL WAS TO NOTIFY ME AND REPLACE AFFECTED PARTS FREE OF CHARGE. SAFETY RECALL BEGAN 1/ 28 / 2011 CALL FEDERAL-MOGUL TO VERIFY THIS SITUATION…”
“HISTORY OF FAILED ATTEMPTS OF DEALER [ WHITTEN BROTHERS, RICHMOND,VA ] TO DIAGNOSIS THIS PROBLEM AND CORRECT IT. PROBLEM IS A HARSH NOISE COMING FROM THE FRONT [UNDER ] THE CAR WHEN A ROAD POT HOLE OR IMPERFECTION [SUBSTANTIAL ] IS RUN OVER. THE NOISE IS PRONOUNCED , INDICATING SOME TYPE OF DEFECT MUST BE PRESENT. THE LAST TIME I WAS THERE AT WHITTEN BROS [5/2009] THE RECALL WHICH WOULD HAVE CORRECTED THIS WAS NOT ISSUED YET... RECALL ANNOUNCED BELOW ..I WAS NEVER NOTIFIED. I AM THE ORIGINAL OWNER AND SHOULD HAVE BEEN NOTIFIED OF THE RECALL BY CERTIFIED MAIL. RECALLED ANNOUNCED 12/27/2010 BY NHTSA. NHTSA REFERENCE # 10E059000 NUMBER AFFECTED : 22,689 SUSPENSION : FRONT : CONTROL ARM : LOWER ARM FEDERAL-MOGUL : RECALLED REPLACEMENT CONTROL ARM ASSEMBLIES PARTS #. K7425 , 10945 , FA4510X...AND K7427 , 10946 , FA4611X NOTE : THESE PARTS CAN FAIL CAUSING THE BALL STUD TO WEAR THRU THE CONTROL ARM HOUSING RESULTING IN NOISE AND OR SEPARATION OF THE BALL STUD FROM THE CONTROL ARM HOUSING. RESULTING IN THE DRIVER LOOSING STEERING CONTROL..CAR CAN CRASH .AT ANY SPEED. FEDERAL-MOGUL WAS TO NOTIFY ME AND REPLACE AFFECTED PARTS FREE OF CHARGE. SAFETY RECALL BEGAN 1/ 28 /…”
“HISTORY OF FAILED ATTEMPTS OF DEALER [ WHITTEN BROTHERS,RICHMOND,VA ] TO DIAGNOSIS THIS PROBLEM AND CORRECT IT. PROBLEM IS A HARSH NOISE COMING FROM THE FRONT[UNDER ]THE CAR WHEN A ROAD POT HOLE OR IMPERFECTION [SUBSTANTIAL ] IS RUN OVER. THE NOISE IS PRONOUNCED , INDICATING SOME TYPE OF DEFECT MUST BE PRESENT.. THE LAST TIME I WAS THERE AT WHITTEN BROS THE RECALL WHICH WOULD HAVE CORRECTED THIS WAS NOT ISSUED YET... RECALL ANNOUNCED BELOW ..I WAS NEVER NOTIFIED ,,I AM THE ORIGINAL OWNER AND SHOULD HAVE BEEN NOTIFIED WITH A RECALL LETTER. RECALLED ANNOUNCED 12/27/2010 NHTSA REFERENCE # 10E059000 NUMBER AFFECTED : 22,689 SUSPENSION : FRONT : CONTROL ARM : LOWER ARM FEDERAL-MOGUL : RECALLED REPLACEMENT CONTROL ARM ASSEMBLIES PARTS #. K7425 , 10945 , FA4510X...AND K7427 , 10946 , FA4611X NOTE : THESE PARTS CAN FAIL CAUSING THE BALL STUD TO WEAR THRU THE CONTROL ARM HOUSING RESULTING IN NOISE AND OR SEPARATION OF THE BALL STUD FROM THE CONTROL ARM HOUSING.. RESULTING IN THE DRIVER LOOSING STEERING CONTROL..CAR CAN CRASH .AT ANY SPEED. FEDERAL-MOGUL WAS TO NOTIFY ME AND REPLACE AFFECTED PARTS FREE OF CHARGE. SAFETY RECALL BEGAN 1/ 28 / 2011 CALL FEDERAL-MOGUL TO…”
“I WENT TO HAVE THE TRANSMISSION LOOKED AT AS IT'S UNDER WARRANTY. I BOUGHT THIS CAR WITH 75,000 MILES ON IT 3 YEARS AGO. SHORTLY AFTER THAT THE TRANSMISSION WENT OUT. WHEN THE MECHANIC PUT ONE IN HE FOUND OUT THAT THERE WAS ALREADY A USED ONE IN THERE. TWO MONTHS LATER THAT TRANMISSION WENT OUT AND IT GOT REPLACED. WELL THIS BRINGS US TO PRESENT DAY WHERE I'M GETTING IT CHECKED OUT AND HAVE THEM CHECK EVERYTHING OUT. THEY TELL ME THAT THE REAR BALL JOINTS ARE OUT AND IT'LL COST $1200 TO FIX IT. I'M LIKE THAT'S NOT WORTH IT. I THEN FIND OUT THAT THIS IS RECALLED. *JS”
“I HAVE THIS CAR FROM 2011, I WENT TO THE DEALER ON BAKERSFIELD CA, TO PROGRAM THE ALARM PAGER, THEY CHANGE THE SHIFT PART BECAUSE HAVE A RECALL, AFTER THAT DAY MY CAR START TO STOP, CHECK ENGINE LIGHT GOES OFF, I CHANGE THE SPEED SENSOR ON THE TRANSMISSION, THE CRAMCHACK SENSOR, THE DISTRIBUTOR, THE MAP SENSOR, THE EGR VALVE, THE FUEL PUMP AND FUEL FILTER, ALL THE RELAYS, THE CAR WORKS FOR A LITTLE AND START TO STOP SUDDENLY, ANYWHERE. SOME TIMES I GO TO THE STORE TO BUY GROCERIES, HE START TO SHAKE FROM THE SUSPENSION, AND THE CAR STOP 2 OR 3 TIMES, ON ONE TRIP. ON AUGUST 15 I WENT TO BAKERSFIELD TO SEE MY DOCTOR BECAUSE I'M PERMANENTLY DISABLE, AND THE CAR STOP ON THE FREEWAY AT SPEED OF 65 MILES, I LET THE CAR FOR A WILE RESTING AND AFTER THAT HE START AGAIN, WHEN I GO OUT ON UNION EXIT THE CAR STOP AGAIN, TODAY I WENT TO THE MARKET AND I HAVE TO PUSH THE CAR ALL THE WAY TO MY HOME. THIS CLASS OF CARS GAVE TROUBLE TO EVERY BODY WHO HAD ONE OF THIS MAKE. NEED HELP TO SEE IF YOU CAN DO SOMETHING WITH THE CHRYSLER CORPORATION. *TR”
Showing 6 of 35 reports. Read every report on NHTSA.gov.
FEDERAL-MOGUL IS RECALLING CERTAIN REPLACEMENT CONTROL ARM ASSEMBLIES, PART NUMBERS K7425, 10945, FA4510X, K7427, 10946, AND FA4611X, SOLD FOR USE ON VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE BALL JOINT ON THE CONTROL ARM ASSEMBLY CAN FAIL CAUSING THE BALL STUD TO WEAR THROUGH THE CONTROL ARM HOUSING RESULTING IN NOISE AND/OR SEPARATION OF THE BALL STUD FROM THE HOUSING.
QUALIS AUTOMOTIVE IS RECALLING CERTAIN AFTERMARKET BALL JOINTS SOLD FOR USE ON CERTAIN PASSENGER VEHICLES. THE SOCKET MAY HAVE BEEN EXCESSIVELY HARDENED WHICH COULD CAUSE IT TO CRACK NEAR THE RETAINING RING GROOVE ALLOWING THE BALL STUD TO SEPARATE UNDER IMPACT LOAD. THE SUBJECT BALL JOINTS WERE SOLD AS FOUR PART NUMBERS, D10945, D10946, G10945, AND G10946. THE AFFECTED CONTROL ARMS, D10945 AND D10946, ARE STAMPED WITH THE FOLLOWING DATES ON THE BALL JOINTS: 134308, 135708, 100109, 102709, 104109, 105509, 107609, 108909, 110309, 113209, AND 116609. THE G10945 AND G10946 ARE THE SAME PART AS THE D10945 AND D10946 RESPECTIVELY. THEY ARE LABELED DIFFERENTLY DEPENDING ON THE AFTERMARKET CUSTOMER.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.