2011 Chrysler Town And Country structure problems

“The contact owns a 2011 Chrysler Town and Country. The contact stated that while her husband was driving at an undisclosed speed, the window glass fell into the door abruptly. A mechanic inspected the vehicle and determined that the failure occurred due to an internal door fracture. The vehicle was not repaired. The contact stated while driving and turning the steering wheel, the steering wheel made an abnormally loud squealing sound. Additionally, the contact stated that the vehicle had difficulty starting, and there was an abnormal amount of smoke coming out of the exhaust pipe. The check engine warning light and the electronic throttle control warning light were illuminated. An unknown dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 174,098.”

“Van was sitting in driveaway in front of my house. We noticed smoke coming from rear of the vehicle and then saw flames. Contacted 911. Fire department arrived to put out the fire. They said something appeared to have shorted or exploded inside the driver side rear wall panel. Just below the rear window vent in the area of the 3 row speakers and cup holders. It burned down the exterior of the van near the gas cap.”

“Rear sliding door lock actuator has failed and is stuck in locked position. It is impossible to open the door from inside or out using either manual or electric opener. This is dangerous as this door can no longer be used in case of emergency or accident. It is also not apparent anything is wrong. It just does not unlock or open.”

“LEFT SIDE PASSENGER AUTO SLIDING DOOR AUTO LOCKING SYSTEM. WHEN SYSTEM WOULD AUTO LOCK, IT WOULD NOT UNLOCK IN EITHER THE AUTO MODE, ELECTRICALLY BY FOB OR DOOR LOCK ELECTRIC SWITCH AND MOST DANGEROUS, UNABLE TO MANUALLY MOVE THE LOCK RELEASE TAB ON THE DOOR TO UNLOCK POSITION. RENDERS EGRESS FROM THIS DOOR TOTALLY IMPOSSIBLE. TROUBLESHOOT FOR 3 WEEKS. AFTER COUPLE DAYS WAS ABLE TO ELECTRICALLY UNLOCK DOOR AT WITCH TIME I TOTALLY DISCONNECTED DOOR POWER AND OPERATED THE LOCK AND DOOR IN MANUAL MODE NO PROBLEMS.. ONLY WHEN USING THE LOCK SOLENOID,,DID THE LOCK SYSTEM JAM. REPLACED DOOR LOCKING ASSMY AT PART COST OF $648 AND DOOR BACK TO NORMAL OPS. PART NUMBER FOR LOCK WAS DLA1306.”

“REAR PASSENGER SLIDING DOORS WILL NOT FULLY CLOSE AND LOCK WHEN PUSHING CLOSE BUTTON. DOORS HAVE TO BE MANUALLY PUSHED CLOSED FROM THE OUTSIDE TO CLOSE THE LAST QUARTER INCH AND TO HAVE THE DOOR CLOSE MECHANISM ENGAGE. THIS PRESENT A SAFETY RISK TO 2ND ROW PASSENGERS AS THE DOORS ARE NOT FULLY SECURED.”

“ON MY DRIVER SIDE THE SLIDING DOOR DOES NOT OPEN, NOT REMOTLEY OR MANUAL. THE LIGHT AT THE OVERHEAD BUTTON TO OPEN THE DOOR WITH COME ON SOMETIMES BUT WILL NOT OPEN THE DOOR EITHER. I CAN HEAR A CLICKING SOUND TRYING TO OPEN THE DOOR WITH THE REMOTE BUT IT STILL WILL NOT MOVE AT ALL.”