2001 Dodge Dakota suspension problems

“The contact owns a 2001 Dodge Dakota. The contact stated while driving approximately 70 MPH, there was a wobble coming from the front passenger’s side tire. The contact was able to pull over and had the vehicle towed to a local mechanic to be diagnosed. The contact was informed that the ball joints needed to be replaced however, the vehicle was not repaired. There was no warning light illuminated. The manufacturer was not informed of the failure. The failure mileage was approximately 300,000.”

“TL* THE CONTACT OWNS A 2001 DODGE DAKOTA. THE CONTACT STATED THAT HE WAS INFORMED THAT THE UPPER BALL JOINT WAS WORN. THE INDEPENDENT MECHANIC INFORMED THE CONTACT THAT THE UPPER BALL JOINTS NEED TO BE REPLACED TO REPAIR THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,647.”

“I STARTED NOTICING A "LURCH OR LATERAL SHIFT" OF THE FRONT END DURING TIGHT LEFT AND RIGHT TURNS AT LOW SPEED (35 MPH OR LESS). DRIVING AT HIGHWAY SPEEDS ON STRAIGHT ROADS DID NOT INDICATE ANY PROBLEMS. RECENTLY, DURING A BRAKE SYSTEM INSPECTION, SIGNIFICANT "SLOP / FREE MOVEMENT" AT THE UPPER BALL JOINT & WHEEL KNUCKLE ASSEMBLY CONNECTION WAS NOTED (> 0.5"). I RESEARCHED THE PROBLEM AND DISCOVERED THE NHTSA ISSUED RECALL FOR "UPPER BALL JOINT FAILURES ON 2000-2003 DODGE DAKOTAS" AS WELL AS THE DODGE ISSUED TSB FOR THE SAME DEFECT. I TOOK MY 2001 DAKOTA IN TO A DODGE DEALER FOR THE RECALL REPAIR. THE DODGE DEALER AND CHRYSLER BOTH CONVENIENTLY TOOK THE POSITION THAT MY VIN WAS NOT PART OF THIS RECALL, THEREFORE THEY WERE NOT RESPONSIBLE FOR MAKING THE REPAIR. MY VEHICLE HAS THE SAME FAILURE MODE DESCRIBED IN THE NHTSA RECALL AND THE DODGE ISSUED TSB. THE NHTSA SHOULD FORCE DODGE TO EXPAND THE SCOPE OF VIN'S COVERED BY THE RECALL TO INCLUDE ALL 2000-2003 DAKOTAS THAT EXPERIENCE PREMATURE BALL JOINT FAILURES. A SAFETY RELATED SUSPENSION COMPONENT SHOULD NOT FAIL AT 50,000 MILES. TO ARBITRARILY EXCLUDE SOME VEHICLE VIN'S FROM THE RECALL EVEN THOUGH THEY HAVE THE…”

“TL* THE CONTACT OWNS A 2001 DODGE DAKOTA. THE CONTACT STATED THAT WHILE REVERSING OUT OF A PARKING LOT, HE HEARD A LOUD NOISE AND WAS UNABLE TO MOVE THE VEHICLE. UPON INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE TIE ROD BROKE. THE VEHICLE WAS TOWED HOME, WHERE THE TIE ROD AND LOWER BALL JOINTS WERE REPLACED. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 169,000 AND THE CURRENT MILEAGE WAS 170,000.”

“TL* THE CONTACT OWNS A 2001 DODGE DAKOTA. THE CONTACT STATED THAT THE PASSENGER SIDE UPPER BALL JOINTS ARM SEPARATED FROM THE WHEEL. THE VEHICLE WAS TAKEN TO A MECHANIC SHOP WHERE THE CONTACT WAS AWAITING REPAIRS. THE DEALER WAS CONTACTED WHO OFFERED NO ASSISTANCE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 140,000.”

“TL* THE CONTACT OWNS A 2001 DODGE DAKOTA. THE CONTACT STATED THAT HE PREVIOUSLY HAD REPAIRS PERFORMED ON THE VEHICLE UNDER NHTSA CAMPAIGN ID NUMBER 04V596000 (SUSPENSION, FRONT CONTROL ARM, UPPER BALL JOINT). HE WAS EXPERIENCING AN ABNORMALLY LOUD SQUEAKING AND CLANKING SOUND WHILE HE WAS DRIVING VARIOUS SPEEDS. THE CONTACT STATED THAT THE IDENTICAL FAILURE RECURRED AFTER THE RECALL REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 94,000.”