2005 Dodge Dakota suspension problems

“*Incomplete Recall Status* ***Defect in transfer case*** Complaint of Manufacturer Defect in 2005 Dodge Dakota Quad Cab 4x4 3.7l v6. While driving at a speed of 30mph on a smooth paved highway and selector switch turned to 2 wheel drive mode; out of nowhere, the transfer case tried to engage 4 High which resulted in SVC 4X4 warning lamp illumination and a loud grinding/stuttering sound from under carriage as well as halting me to 10 mph without any help from me. after pulling over on the roadside and putting truck in park and turning the engine off, i waited a couple of minutes and SVC 4X4 indicator and 4High dash light had gone. I restarted the truck only to find that the SVC 4X4 Warning lamp immediately returned and now the 4lo illuminated dash light is constantly showing and truck is still showing in 2 wheel drive with selector switch but 4x4 will not engage at all now. Took to a mechanic shop 1/2 mile down the road and had it read for any DTCs and inspected. Code came back as C1404. Transfer case still tries to engage as soon as truck door is opened and dome light comes on. SVC 4X4 warning indicator stays on the dash lit up and 4lo warning light flashes non…”

“I TOOK MY 2005 DAKOTA TO REPAIR SHOP BECAUSE OF CLUNKING NOISE ON FRONT DRIVERS SIDE. NOISE WAS HEARD WHEN DRIVING OR ROCKING THE TRUCK WHEN IT WAS PARKED. REPAIR SHOP SAID LOWER BALL JOINT COMPLETELY FAILED AND WAS RIDING ON LOWER CONTROL ARM INSTEAD OF SUPPORTED BY BALL JOINT. UPPER BALL JOINT WAS ALSO BAD. PASSENGER SIDE UPPER BALL JOINT WORN OUT AND LOWER BALL JOINT BOOT WAS CRACKED. ALL TIE ROD ENDS ALSO NEEDED TO BE REPLACED.”

“HELLO, I RECENTLY PURCHASED A ONE OWNER 2005 DODGE DAKOTA, WHICH HAS LESS THAN 35,000 MILES AND HAS BEEN VERY WELL MAINTAINED. THE CAR FAX CAME BACK CLEAN FOR ACCIDENTS ETC, BUT I HAVE FOUND, THAT BOTH THE FRONT AND REAR SECTIONS OF THE CHASSIS HAD TO BE REPLACED ON DRIVER AND PASSENGER SIDES AND MOST OF THE FRONT SUSPENSION HAD TO BE REPLACED TOO. DUE TO EXCESSIVE DEEP RUST. TO THE POINT OF THE NUT HOLDING THE LEFT OUTER TIE ROD END DISINTEGRATED. THE STRAIGHT SIDE RAILS OF THE CHASSIS ARE EXCESSIVELY DEEP RUSTED. AS WELL AS THE OIL PAN AND REAR AXLE HOUSING (WHICH ARE ORIGINAL). THE DEALERSHIP HAD TO CUT OFF THE FRONT SUSPENSION COMPONENTS AND REPLACE ALL BUSHINGS AND MOST OF THE FRONT SUSPENSION COMPONENTS. DUE TO EXCESSIVE RUST AND WEAR. MY TRUCK HAS BARELY BEEN ON THE ROAD FOR ITS YEAR AND HAS HAD MINIMAL EXPOSURE TO ROAD CHEMICALS SUCH AS SALT ETC. THESE COMPONENTS ROTTING AWAY TO THIS EXTENT WITH SUCH LOW MILEAGE REGARDLESS OF AGE INDICATES THE USE OF POOR QUALITY MATERIALS BEING USED DURING ASSEMBLY AND POSING A POTENTIAL SAFETY ISSUE TO CONSUMERS. I OPENED A CASE# 57271603 WITH CHRYSLER AND THE AGENT TOLD, THAT EVEN IF THE CASE WAS MOVED UP FOR REVIEW…”

“AROUND 50,000 MILES UPPER AND LOWER BALL JOINTS MAKING POPPING SOUNDS. TOOK TO LOCAL REPAIR SHOP . REPLACED ALL 4 , THEN POPPING STOPPED. WAY TO EARLY FOR BALL JOINT REPLACEMENT. OCCURED WHILE MOVING 5 MPH AND TURNING EITHER DIRECTION.”

“TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. WHILE DRIVING APPROXIMATELY 45 MPH, THE REAR OF THE VEHICLE AGGRESSIVELY SWAYED TO THE LEFT WITHOUT WARNING. THE DRIVER LOST CONTROL OF THE VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO A DITCH AND THE VEHICLE ROLLED OVER SEVERAL TIMES. THE CONTACT STATED THAT THE REAR AXLE DETACHED FROM THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED. A POLICE REPORT WAS FILED. THE CONTACT RECEIVED INJURIES TO THE FACE, CHEST, STOMACH, LEG, AND FEET AREAS. MEDICAL ATTENTION WAS NOT NEEDED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 173,000.”

“TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. WHILE DRIVING AT LOW SPEEDS DOWN A MOUNTAIN, THE FRONT DRIVER SIDE WHEEL DETACHED FROM THE VEHICLE WHILE BRAKING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRIVER SIDE TIE ROD AND HUB ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 77,105.”