2007 Dodge Durango fuel system, gasoline problems

“FUEL OVERFLOWS FROM THE INLET WHEN FUELING THE VEHICLE. IF YOU ATTEMPT TO ACTUALLY FILL THE TANK (WHICH I ONLY GET 20 GALLONS INTO A 27 GALLON TANK EVEN WHEN THE LOW FUEL LIGHT COMES ON), THE FUEL WILL OVERFLOW OUT OF THE INLET AS SOON AS THE HANDLE CLICKS OFF. IT'S NOT A SMALL AMOUNT OF OVERFLOW EITHER, IT'S ENOUGH THAT THE FUEL ENDS UP DOWN THE SIDE OF THE VEHICLE AND INTO A PUDDLE ON THE GROUND. THIS HAS CAUSED THE ONLY SURFACE RUST ON THE ENTIRE VEHICLE. *TR”

“TL* THE CONTACT OWNS A 2007 DODGE DURANGO 4X4 LIMITED. THE CONTACT STATED THAT WHEN REFUELING, GASOLINE WOULD SPILL FROM THE FILLER NECK. THE FAILURE WAS RECURRING. THE DETERMINED MALFUNCTION WAS A FAULTY FUEL CHECK VALVE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 18,000. ..UPDATED 04-29-14 *BF”

“TL*THE CONTACT OWNS A 2007 DODGE DURANGO. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING REFUELED, FUEL SPILLED TO THE GROUND AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC SEVERAL TIMES FOR THE FAILURE. THE 02 SENSOR WAS REPLACED NUMEROUS TIMES BUT THE FAILURE WAS NOT CORRECTED. THE CHECK ENGINE LIGHT REMAINED ILLUMINATED AND THE FUEL CONTINUED TO SPILL TO THE GROUND WHEN REFUELING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,053 AND THE CURRENT MILEAGE WAS 82,100. UPDATED 05/31/12*LJ”

“TL* THE CONTACT OWNS A 2007 DODGE DURANGO. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, GASOLINE WOULD SPEW OUT FROM THE FILLER NECK. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 66,000.”

“AS WITH THE 2005 DURANGOS & THE MANY 2007 DURANGO COMPLAINTS, I TOO HAVE ISSUES WITH THE FUEL SPEWING OUT FROM THE FILLER NECK AFTER THE PUMP HAS SHUT OFF. THE AUTOMATIC SHUT OFF (FUEL INTAKE CHECK VALVE) IS NOT FUNCTIONING PROPERLY & ALLOWS QUITE A BIT OF FUEL TO SHOOT OUT FROM THE VEHICLE. THIS IS NOT ONLY A SAFETY CONCERN, BUT IT HAS ALSO CAUSED THE PAINT ON MY VEHICLE TO BEGIN BUBBLING UP, WHICH WILL EVENTUALLY CAUSE A RUSTING ISSUE. I HAVE TO USE THE WINDSHIELD CLEANER BRUSH AT THE PUMP STATION TO WIPE THE EXCESS FUEL OFF MY VEHICLE TO PREVENT ANY FURTHER BUBBLING. THIS PROBLEM NEEDS REPORTED & A RECALL ISSUED. IT'S RIDICULOUS! *TR”

“I BOUGHT THE VEHICLE NEW AND NOTICED WITHIN THE FIRST 1000 MILES WHEN FILLING UP AND USING THE AUTO SHUT OFF, GAS WOULD SPILL OUT OF THE TANK ON THE SIDE OF THE CAR. I THOUGHT IT WAS THE PUMP ITSELF AND TRIED OTHERS. I WAS TOLD BY LOCAL DODGE DEALER THERE WASN'T A PROBLEM AND NO CHECK ENGINE LIGHTS WOULD EVER COME ON INDICATING AN ISSUE. MY FUEL CAP HAS BEEN REPLACED SEVERAL TIMES BUT I CAN'T USE AUTO SHUTOFF ANY MORE WITH THIS VEHICLE. I'VE GOTTEN USE TO NOT FILLING UP BUT HAVE BEEN TOLD BY OTHERS THIS COULD BE DANGEROUS. MY CAR GOES IN THE SHOP TUES 1/9/12 UNDER WARRANTY AND WONDERING WHAT THEY WILL SAY. *TR”