2015 Dodge Grand Caravan electrical system problems

“The passenger side sliding door is locked into place the power actuator has gone out. An entry way is locked putting people in danger, one way in one way out for 5 rear passengers. Multiple model years have a reoccurring issue.The failure of the sliding door lock actuator is so common that it prompted thousands of owner complaints to the National Highway Traffic Safety Administration (NHTSA). While it never led to a formal safety recall, NHTSA did open a preliminary evaluation (PE21-016) In response, Chrysler (FCA/Stellantis) issued several Technical Service Bulletins (TSBs), including TSB 23-017-20 and TSB 23-001-25, instructing dealers to replace the faulty actuator rather than the entire latch assembly. No warning signs of failure dealership is saying my vin doesn't count but I'm within 15 years of vehicles service and under 150000 miles.”

“Cracking front windshield (temporarily fixed by clear tape), broken window regulator motors on both passenger and driver sides stop lifting the glasses up and down, passenger side plastic window part (vertically snapped on the upper part of passenger door) fell off, engine light sometimes on and off with unknown detected problems.”

“Went to roll down the window on the drivers side panel and it started to smoke and short circuit. We removed the panel because we believed of could have caught fire. Problem has not been replicated due to dealership service department being closed. There were no warning lamps or messages and had occured randomly when using the panel.”

“The contact owns a 2015 Dodge Grand Caravan. The contact stated that whenever the passenger’s side sliding door was opened by the fob or from inside the vehicle, there was an abnormally loud clicking sound heard. The contact stated that while inspecting the door, the contact became aware that the door had failed to close securely. The contact released the child safety lock on the door enabling the door to be locked securely; however, the clicking sound remained. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was made aware of the failure, and confirmed that the VIN was not under recall or Warranty. The failure mileage was 149,992.”

“There are multiple whirring and clicking noises in the walls of the cargo area, mostly in passenger side. This happens when I lock/unlock the auto, and close the doors. I also hear what sounds like a moan coming from the dash, at least 2-3 times after I've closed and locked it, from the inside. I just purchased it used, with around 98k miles on it.”

“The driver side passenger sliding door lock actuator is frozen, keeping the door perpetually locked. The passenger sliding door actuator will not lock at all, so the passenger sliding door is perpetually unlocked. I've been told by an auto mechanic that the passenger side sliding door is in danger of permanently locking as well. If that's the case, passengers will have to enter by the front doors (or the back hatch, which is too inconvenient). In the case of an accident, I'm concerned that exiting the vehicle will be dangerous for backseat passengers. I understand that there's an extended warranty for the 2015 Dodge Grand Caravan lock actuators, but the extended warranty only includes those manufactured after May 1, 2015. My 2015 Dodge Grand Caravan was manufactured February 2015. My family budget is really tight, and the prospect of putting $1500 to $2000 down for repairs to these doors is cost prohibitive. The doors are available for inspection. The vehicle has been inspected by a local auto service center mechanic and the actuators were confirmed as the problem by the service center. There was no warning of failure of the actuators beforehand.”