2016 Fiat 5 Series electrical system problems

“3 times my car had died going under 30 mph, it must turns off or goes into this neutral position and won’t let me change gears, when i restart it, the engine makes an awful squealing sound. all these “drive mode unavailable “ “check esc system” “service electronic brake” it seems it is related to the S55 / 16V529000 safety defect …. “intermittent switch to neutral while driving””

“The contact owns a 2016 Fiat 500X. The contact stated that while attempting to start the vehicle using the Push-to-Start button, the engine failed to crank or start. The vehicle was started after the fifteenth attempt. Additionally, the contact stated that the brake pedal was extremely firm and difficult to depress while attempting to start the vehicle. The vehicle was taken to a dealer, but the cause of the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.”

“I was driving vehicle and it all of a sudden get stuck in gear in either park gear or some other gear that wont allow me to turn engine off. Sometimes it just slow down to a stop and will not go into gear again for a while or appears the gears are not engaging putting me at risk for accident on highway. Once it slowed down in traffic and I nearly got hit trying to drive it off the highway. The gears were not engaging putting me at risk of many vehicles hitting me. I was praying someone noticed I had car trouble to slow down as I was no longer in full control of vehicle. After some”

“The contact owns a 2016 Fiat 500X. The contact stated that while driving at an undisclosed speed, the transmission unintendedly shifted from drive(D) to neutral(N). The RPM became elevated; however, the vehicle failed to accelerate as intended. While driving approximately 15 - 20 MPH, the vehicle went into LIMP Mode. While in LIMP Mode, the contact coasted to the side of the road and waited for several minutes before continuing to drive. The failure had occurred twice. Additionally, the check engine warning light illuminated intermittently. The vehicle had been taken to a certified mechanic, who determined that the transmission had failed and needed to be rebuilt. The dealer also diagnosed that there was a failure with the instrument cluster. The instrument cluster lights were cleared; however, the transmission was not repaired. The check engine warning light remained illuminated. The contact was made aware of NHTSA Campaign Number: 16V529000 (Power Train), for the transmission for the same year, make, and model. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall and opened a case. The failure mileage was approximately 144,000.”

“I am writing to you in regard to my 2016 FIAT 500X about multiple concerns. 1. There has been an open recall on the Emissions system since 2022. I immediately followed up and was put on a waitlist as I was told that the parts were on back order. I was told I was 27 on the waitlist. I followed up every 3-6 months for an update on getting the recall repaired but was told they have no update on the parts. It is now 2025 and my registration and inspection are expired. I was informed by FIAT service mechanic that the open recall should not impact my inspection. Upon bringing it in for inspection, I needed to get the thermostat replaced, which was one of the first recalls that was rectified upon purchasing the car in 2017. My car failed inspection. I followed up with FIAT corporate and was assigned a case manager who followed up as well unable to rectify the situation. Now my car is unsafe to drive, I have gotten a ticket for expired inspection . I told the officer that there is an open recall and that I am at the mercy of FIAT. Secondly since I purchased the car I have brought it back multiple times, expressing concern that the car lags when you press the gas. If I…”

“El auto se detuvo sin avisar solo ya no quiso acelerar. Me marcó muchas fallas en las cuales les tomé foto, me tuvieron que remolcar y mi hijo se pegó en la cabeza, por suerte nada grave. Pondre las fotos de los códigos que aparecen. Tuve q ser remolcado hasta ahorita la batería sigue en un 47% pero aún así sigue sin funcionar el vehículo”