2019 Ford Ecosport power train problems

“I am filing a safety complaint regarding my 2019 Ford EcoSport and Ford’s repeated failure to properly complete a safety recall. In XXX, my vehicle displayed an oil-pressure warning while driving, just two days after an oil change. I brought it to Woodbridge Ford in [XXX] for recall repairs. They kept my vehicle for three months before claiming it was repaired. However, I continued receiving notices stating the recall was incomplete. In XXX, I contacted the dealership, now Freedom Ford, and was informed that the recall had NEVER been completed. I returned my vehicle for repairs. On XXX, I was told my vehicle was ready. Before I could even leave the dealership lot, the vehicle began shutting down and entering an idle/reduced-power mode. A dealership employee test-drove it and experienced the same malfunction. The dealership kept my vehicle. After repeated attempts to obtain answers, an employee named [XXX] confirmed that parts were MISSING, the vehicle had not been properly reassembled, and additional parts needed to be ordered. He could not explain what happened to the missing components. He also confirmed the vehicle continued malfunctioning while being…”

“2019 Ford EcoSport 1.0L, VIN [XXX], 23,338 miles. Ford Safety Recall 23S64/NHTSA 23V-905 was performed by Rod Baker Ford in September 2025. Repair order XXX was opened XXX and the recall work was completed/invoiced XXX at approximately 22,812 miles. The repair included replacement of the timing belt, oil-pump drive belt and oil-pump drive-belt tensioner. The Ford repair order documents the 23S64 completion and the replacement parts. On XXX, at approximately 23,338 miles, the engine suffered a catastrophic failure in traffic. This was only approximately 526 miles after the 23S64 repair. Initial diagnosis found no compression. Hawk Ford subsequently diagnosed failure/collapse of timing-belt tensioner CM5Z-6K254-A. Ford's 23S64 repair procedure required replacement of the timing belt but reused the existing timing-belt tensioner. That tensioner had to be compressed/locked and reused during installation of the new timing belt. Less than one year and only approximately 526 miles later, that tensioner collapsed and the engine suffered catastrophic damage. Ford has declined to participate in the engine repair/replacement. Ford Customer Care case XXX. I am reporting…”

“My car has been in and out of the shop since 2024 due to the power train system. As this is an active recall case my car was repaired 5 times. Recently, with the recall part replaced in January 2026, I got my car back and in May 2026 while driving, my car once again loss power. Going from 50 to coasting. After many guarantees that the problem is fixed, I continue to have the same dangerous problems.”

“So my car is about to be out of warranty and I have called and made two appointments to get my recall taken care of as it is a safety risk for me and my kids. They canceled the first one with no communication and the second appointment they called and said they can’t get the part in so I have to call them in 2 weeks to check. After two weeks I believed my car will be over the 60k mark putting me out of warranty and voiding them to fix any issues that occurred because of this recall.”

“This is now going to be the FOURTH time we are going to have to put a NEW engine in the same exact car. We just replaced the engine barely a year and a half ago.”

“Engine and Transmission failed at 46,000 miles even though under a extended warranty Ford short changed us to where we had to pay $7200.00 to get the car fixed. This car is the worst for failures of the powertrain. Never will buy another Ford ever.”