2014 Ford Edge power train problems

“horn stopped working for unknown reasons fuses were checked, all good fuses same with relays and clock springs, horn appears too no longer work on my vehicle the vehicle only has 121k miles, check engine light popped on and all it says is spark plugs got the coils and plugs done same issue. got a dignosis done piston rings have failed at 121k miles. cv axle issue has became disconnected from joint. expensive repair.”

“The contact owns a 2014 Ford Edge. The contact stated that while driving at slower speeds, the vehicle hesitated while accelerating with the accelerator pedal depressed, and the vehicle to respond as needed. The check engine warning light was illuminated. The contact stated the vehicle was consuming an excessive amount of fuel, with an abnormal burning metal odor entering the cabin of the vehicle through the air vents. The contact scanned the vehicle with an OBD-2 scanner and retrieved error codes for the Power Control Module, Steering Column Control Module, and Power Train Control Module. The vehicle was taken to a local dealer to be diagnosed; however, the cause of the failure was unknown because the contact had previously cleared the error codes twice. The contact related the failure to Manufacturer Recall: 24E10; however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 108,000.”

“7/2/25-i was driving about 20 miles per hour when suddenly my car went into a type of limp/idle mode. It shut the car down to an idle, a wrench light came on my dash then the car started to shake. I coasted into a driveway and turned the car off. I turned it back on after 5min and it was fine. 7/16/25-I was driving about 30mph and all of a sudden my car goes into this idle mode again. I got the car to coast over into a turning lane. It lost power down to an idle, wrench came up on dash again then the car started to shake. I turned the car off and back on and it was fine. I’m very scared to drive my car bc I don’t know when this will happen again. It could be when I’m turning in front of another vehicle, driving on the expressway or just normal streets or if someone was behind me and wasn’t able to react appropriately bc my car goes into this idle mode so fast that I don’t know how to keep from having an accident myself. 7/17/25-I took it to a machanic and they hooked it to a computer but nothing showed up as being wrong. They drove it several times but they couldn’t get it to do what I’m explaining what it does. After researching the issue, I believe it may be…”

“The Power Take Off Assembly (PTU) failed. I had it replaced a a Ford Dealership with a genuine Ford PTU. After driving less than 125 miles the PTU failed again and my right front half shaft disengaged without notice on the high when traveling at highway speeds. Upon return to the dealership they noted that the PTU failed and it was replaced at no cost. However, they charged me for the replacement of the Right Front Axel. I contacted Ford Customer Service and contend that recall 14S10 should apply especially after the new PTU failed. They denied my claiming stating that the dealership claimed a torn CV Boot was the cause of my axel disengaging. However there was no mention of a torn CV Boot in the dealerships multipoint inspection of my vehicle when originally brought in. Ford Customer Service and the dealership denied my claim.”

“The rear differential has failed. It started to fail at 80,000 miles. The car now has a little over 91,000 miles. It makes a whining/grinding noise at over 30 miles per hour. It was subtle at first but has become much louder recently. If this had failed completely while on the highway going 55 MPH or higher, this could have resulted in complete loss of control of the vehicle. Additionally, oil or parts could have been left on the highway becoming a hazard for other drivers. The local mechanic confirmed that this is the part that needs replacing. There were no warning lights or messages at all. This is a major part of the drivetrain and there are many people on the Internet complaining about premature failure of the differential on the Ford Edge and Lincoln MKX. I am surprised there has not been a recall on this already. Please look into it.”

“Pulled out of a parking lot onto a busy street locally, car lost power and the orange wrench light came on. Would not go, all the car did was jerk and sputter. Engine did not shut off but would only coast/roll into the middle lane and managed to coast/roll into another business parking lot next door to where I pulled out from and once parked, I turned ignition off and back on. Wrench light went out and car started. No codes were apparently shown when hooked up to the machine at the car lot the next day (wrench light was still off) this is very scary and very dangerous whatever it is, it needs investigated and fixed so us Ford edge drivers can feel safe when driving. Also 1 week before this my check engine light came on, same code 3 times came up for eval, emissions ECT... Now no codes are showing since the wrench light came on Sunday and my car stopped moving.”