2009 Ford Escape power train problems

“The contact owns a 2009 Ford Escape. The contact stated that on several occasions while driving at various speeds, the power train warning light illuminated randomly but disappeared. Additionally, the contact stated that on several occasions when the vehicle was started, the steering wheel became stiff and was difficult to turn. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 190,000.”

“I have had to spend over $5,000 in repairs for this vehicle and I’ve had it for over a year. It was listed at $6,999 at a used car dealership so I got it as is and have had issues ever since. There is no recall on my car according to the VIN# however I strongly disagree with that. When I first got it, it drove great for a week and then the problems started to arise. Every time I came to a complete stop the car would turn off completely. So I would have to put it in park and turn the key off then restart it and keep it moving a little. This kept going on for 11 months, until it turned off at a stop light and I couldn’t get it to start back up. I was almost hit by traffic coming up behind me (going no less than 45 mph) because of where the car was located. Turns out the motor basically combusted from the inside out. This was caused by the oil leak that could never get fixed because the gasket would always give way. After having to work for 4 months scraping together $3,200 plus paying for a rental car weekly, the motor was replaced and it was working well again. Until it wasn’t. The power steering is controlled by an electric pump which makes you more prone to…”

“First steering column locked with less then 65,000 miles . Now power train wrench light warning popped on less then 80,000 miles . Throttle body issue forcing car into limp mode leaving driver in danger on the road”

“Subject vehicle was a 2009 Ford Escape with 74,123 miles. Driving the vehicle the front passenger lower control arm separated from the k-frame/cradle causing the vehicle to lose control. Loss of steering was experienced as well as tire lock up from the front tire lodging against the back of the fender. The CV shaft also separated during the failure resulting in loss of transmission engagement. There was no warning prior to the event, the failure was sudden and immediate. The loss of vehicle control was extreme. Failure is identical to RCRIT-14V165-9596 for the 01-04 Escapes. The reason the recall was only isolated to the 01-04 Escapes is unknown. In my opinion, whatever PCA actions or supplier related issues identified by Ford Motor Company during the prior recall investigation to support the recall only affecting 01-04 model years was either incomplete or inaccurate. The frame rust through condition extends beyond the model years listed in the recall and was not resolved as shown by subsequent failures on vehicles outside of the recall model year window. No mechanism was put in place to prevent the control arm separation in the later model year Escapes to…”

“Subject vehicle is a 2009 Ford Escape with 74,123 miles. Driving the vehicle the lower control arm separated from the front frame otherwise known as the engine cradle or subframe. The failure is identical to the subframe failures on the 2001 - 2004 Ford Escapes currently under recall. The failure was immediate with no prior warning. The vehicle exhibited loss of steering control, wheel lock up from the front tire contacting the back of the wheel opening, and loss of transmission engagement from cv joint separation. In my opinion, whatever PCA actions or quality root cause was identified by Ford Motor Company during the prior recall investigation isolating the condition to 2001 - 2004 Escapes was either incomplete or inaccurate. This is supported by the same failure occurring in Escapes outside of that model year window. No mechanism was added after the 2004 Escapes were produced to prevent this failure from occurring. Images attached show the failure that was experienced. I was unable to obtain a good used frame locally that did not exhibit signs of corrosion with perforation present or starting. This further supports the failure mode is beyond the scope of the…”

“I SUDDENLY LOST POWER WHILE DRIVING ON CITY STREETS AND HAD THE CHECK ENGINE LIGHT AND WRENCH LIGHT COME ON. UPON RESEARCHING THE ISSUE IT WAS FOUND TO MOST LIKELY BE A FAULTY THROTTLE BODY. ALSO I CAN NOT DRIVE ON THE FREEWAY FOR MORE THAN 5-10 MINUTES AT 60 MPH BEFORE IT STARTS TO SHIMMY AND BECOME UNSAFE TO DRIVE.”