2022 Ford Escape service brakes problems

“While traveling on the interstate, the driver of the Ford Escape moved into the left lane from behind an 18-wheeler that had stopped while attempting to enter a turning lane. After moving into the left lane, the driver observed traffic ahead stopping. The vehicle ahead was at or beyond the front of the 18-wheeler. The Escape was still behind the rear of the 18-wheeler when the driver began braking. The driver pressed the brake pedal, but the vehicle did not stop as expected. It may have slowed slightly at first. The driver released the brake pedal and pressed it again. On the second application, the vehicle did not appear to slow further, and the brake pedal felt as though it went straight to the floor. The driver continued holding the brake pedal down until the Escape collided with the vehicle ahead, which was at or beyond the front of the 18-wheeler's cab. The driver had applied the brakes twice before the vehicle's forward-collision/impact warning activated. There were no known brake warning lights or brake-related messages before the incident. The suspected system involved is the braking system; the exact cause is UNKNOWN. The collision resulted in the…”

“Warning message appeared on dash as I was braking. Reduced braking power. I had pushed on brake pedal almost to the floor & missed turning at a corner. My car also makes noise upon backing up each day.”

“The contact owns a 2022 Ford Escape. The contact stated that while reversing, there was an abnormal grinding sound coming from the brakes. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the failure persisted. The vehicle was taken back to the dealer and the brake pads and rotors were replaced; however, the failure persisted. The contact stated that when the weather was humid or it rained, the sound was louder. The contact related the failure to TSB: 23-2308 (Moaning Noise When in Reverse; in cold weather and/or high humidity); however, the vehicle was not included in the TSB. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 1,000.”

“The contact owns a 2022 Ford Escape. The contact stated that while depressing the brake pedal there was an excessive amount of brake dust coming from the front brake pads. Additionally, there was an abnormal banging sound coming from the vehicle. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was contacted and filed a claim and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 35,000.”

“Vehicle has an issue with braking system. When attempting to stop, the brake pedal required much more force to be applied that subsequently increased stopping distance. Safety to operator and/or others is at great risk due to extended stopping distances. The condition has not been confirmed by the dealer service department or independent service center. However, this condition occurred to the owner of the vehicle as well as the vehicle owner's son (that is in the auto industry as an insurance adjuster). The dealer only looked at the condition of the brake pads, calipers, and rotors. The dealer did not look into the hydraulic braking system or brake lines. (NOTE: There is an open recall on many Ford Escapes, however, this particular vehicle identification number is outside the current recall notice. I believe they should investigate and/or expand the recall to add more vehicles due to our discovery) The vehicle has not been inspected by the manufacturer, police, insurance representative or others. No ODB Codes or warning lights appeared on the dash information screen.”

“While going on the highway it braked hard and displayed service stabilitrak light with traction control light flashing went away after 10 seconds. Then I pulled into my driveway and it snapped the wheel out of my hand forcefully almost breaking my wrist and wouldn't let me turn right. Towed it to ford where they claim a loose battery terminal was present. No warning at all before this. Upper engine noise too (possibly pulley) 28k miles and trans is shifting hard as well. The trust for the vehicle is gone. I have a video as well of the steering wheel snapping.”