1997 Ford Escort electrical system problems

“TL* THE CONTACT OWNS A 1997 FORD ESCORT. WHILE DRIVING APPROXIMATELY 35 MPH, THE POWER STEERING SEIZED WITHOUT WARNING. THE VEHICLE HAD TO BE TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRES AND FUSES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.”

“AIR BAG CONTROL DIAGNOSTIC MODULE SHORTED OUT DUE TO RUPTURED HEATER CORE. WHEN I SPOKE WITH THE LOCAL DEALERSHIP THEY TOLD ME TO CONTACT A LOCAL JUNK YARD. THERE IS A RECALL ON THIS ITEM. I NEVER RECEIVED A RECALL NOTICE. *TR”

“TL*THE CONTACT OWNS A 1997 FORD ESCORT. WHEN MAKING A RIGHT TURN AT VARIOUS SPEEDS, THE CONTACT HEARD A CLUNKING SOUND COMING FROM THE FRONT END BALL JOINTS. THE DEALER STATED THAT THE BRAKE PADS, ROTORS, DRUMS, AND FRONT WHEEL BEARING ON THE PASSENGER SIDE NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE ODOMETER AND SPEEDOMETER HAVE BOTH BEEN REPLACED THREE TIMES, BUT SHE DOES NOT TRUST THAT THE SPEEDOMETER IS CURRENTLY WORKING PROPERLY. THE FAILURE MILEAGE WAS 115,000. UPDATED 06-03/08. *LJ THE TIE ROD END, REAR SPRING, WINDSHIELD, UPPER BALL JOINT, ODOMETER KNOB, REAL PASSENGER SEAL WERE ALL REPLACED. UPDATED 05/30/08”

“WHILE PARKED HORN WENT OFF ON ITS OWN. OWNER HAD TAKEN FUSE OUT TO STOP HORN FROM BLOWING. SPOKE TO DEALER & INFORMED SMALL PLASTIC PIECE HAD WORN AWAY BETWEEN HORN & AIR BAG MODULE. IT NEEDED TO BE REPLACED. SEEMS TO BE A VERY COMMON PROBLEM AND WAS OBVIOUSLY A HAZARD (COULD POSSIBLY PREMATURELY ACTIVATE OR FAIL TO ACTIVATE THE AIRBAG). NO SOLUTION FOR THIS PROBLEM HAS BEEN ADDRESS BY THE MANUFATURE TO MY KNOWLEDGE! OUTSIDE TEMPERATURE IS NOT A FACTOR AT ALL, OCCURS ON HOT, COLD OR RAINY DAYS. *AK”

“DT*: THE CONTACT STATED WHILE THE VEHICLE WAS IN AN IDLE POSITION A SMELL OF SMOKE WAS OBSERVED COMING FROM UNDERNEATH THE DASHBOARD. UPON INSPECTION, THE ENGINE FUSE BOX WAS FOUND TO BE BURNT. BEFORE THE SMOKE ERUPTED, THE AIRBAG LIGHT ILLUMINATED FOR A FEW SECONDS AND THEN BLINKED ONCE. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO DETERMINED THAT THE CONDENSATION FROM THE EVAPORATOR CASE MAY HAVE DRIPPED ONTO THE AIRBAG DIAGNOSTIC MONITOR OR WIRING HARNESS. THE DEALER REFUSED TO PERFORM A SECOND REMEDY REPAIR UNDER RECALL # 02S44. THE MANUFACURER WAS CONTACTED HOWEVER THEY CONFIRMED THE DEALER'S CONSENSUS.”

“DT: THE VEHICLE HAD AN ELECTRICAL SHORT AND BURNED UP ALL OF THE WIRING. *AK WHEN THE CONSUMERS WIFE STARTED THE VEHICLE SHE NOTICE SMOKE COMING FROM THE STEERING COLUMN. *JB”