2019 Ford Expedition power train problems

“At neighborhood speeds the transmission shifts roughly around 4th gear, making clunking noises and lurching the vehicle. This happens on a daily basis. At interstate speeds, the transmission has popped out of gear when attempting to pass another vehicle, leaving the vehicle decelerating dangerously in a situation where acceleration is needed. This has happened twice in the last year and requires navigating out of traffic to allow the transmission to figure out what is going on and re-engage the proper gear. I have been lucky not to have been in a serious accident. It has not been inspected by a dealer but, when mentioned to a dealer, was told that is just what you get with that 10-speed transmission. In both instances there was some type of warning displayed on the console but I was too busy trying to survive to notice what the message said.”

“Since early in purchasing our 2019 Ford Expedition, we were getting powertrain warnings (pictures attached from August 2019). We took the vehicle in to have it diagnosed but the dealer said there were no codes and nothing they could do to troubleshoot. Fast forward to after the warranty expires the car starts behaving erratically when it's changing gears, especially when downshifting. On more than one occasion when towing our boat, I would press on the gas to pass a semi truck and there would be a loud CLUNK that you could feel and then the motor would simply rev indefinitely as if the transmission had switched to neutral. It's very dangerous losing power on a freeway with traffic including semi trucks and towing a boat. It got to the point where it would be very jerky just driving, particularly (it seemed to me) when the car had been sitting. This has happened several times. I did some research and found there were 4 TSB's for this issue and is an issue for all of the Ford 10 speed transmissions for Expedition, F150 and even the Mustang. I reached out to the dealer with these TSB's and they diagnosed that our car did have this troubled transmission and we did…”

“While accelerating from a stop after a traffic light, the transmission briefly shifted into neutral on its own, causing a momentary loss of motive power. The vehicle recovered on its own without stopping. This has happened once so far. The transmission also slips rarely at other times. The dealer has not inspected the vehicle yet. This vehicle has an open NHTSA recall, campaign 26V402 (Ford 26S48), for the transmission potentially engaging Park while the vehicle is moving.”

“The car has started uneven acceleration and lurching when driving. A local Ford dealer service department has recognized this as a known problem requiring the replacement of the transmission CD drum. Uneven driving creates a risk when driving.”

“Our 2019 Ford Expedition Max Platinum (VIN [XXX]) is covered by NHTSA recall [XXX] / Ford recall 26S48 for the transmission park system defect. Transmission problems began not long after purchase, within the warranty period. The transmission shifted hard and banged loudly during acceleration. We reported this to the dealer on multiple occasions. The dealer's repeated response was PCM reprogramming, which never corrected the condition, and the dealer repeatedly stated they could not replicate the problem. The transmission was never repaired under warranty. In XXX, an independent shop, [XXX], diagnosed a stored TCM code P07E6, "Stuck in Park." The vehicle now attempts to shift into Park on its own and jumps out of gear while driving. It is barely drivable. The dealer quoted approximately $9,867 to replace the transmission and did not acknowledge the open recall on the VIN, despite the recall appearing in both NHTSA's and Ford's own VIN lookups. I contacted the Ford Customer Relationship Center referencing recall 26S48. The representative stated nothing could be done because this is an advance-notice recall, refused to open a case number, refused escalation to a…”

“The contact owns a 2019 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the vehicle jolted, the vehicle failed to maintain the intended speed, with an abnormal squeaking sound as if the brakes were engaged, even though the brake pedal was not depressed. The message "See Service Manual" was temporarily displayed. The local dealer was contacted. In addition, the contact stated that, as per the Ford App, there was no failure identified. The manufacturer was made aware of the failure. The failure mileage was approximately 84,000.”