2004 Ford Explorer Sport Trac steering problems

“On two incidents this week when steering wheel is cut to maximum left or right in tight parking lot and narrow road while making tight turns at legal speeds the engine (V8 4.6L) stalls. Brought to non-Ford mechanic for inspection(NYS ANNUAL) and passes but mechanic looked for a power steering pressure sending sensor or switch that is to give signal to EMC to increase idle to compensate for more power steer demands. Part is $35 at Partgeek but mechanics dont know where the harness the sending switch is located, if one exists or is it in power steering pump. Call Ford NADA! Call two local Ford dealers. One says dont work on cars 15 years old, other says go to liabary to get diagrams, Ford says obsolete parts in 10 years.Bummer! Husband ordered 8/10/20 New 2021 Bronco. Pushed into 2022 due to supply chain. Found out Bronco built at MAP same as Ranger, will not get stronger 10r80 transmission,but Explorer 10r60, 25% weaker ; and gets Explorer 2.3L EgoBoost non- Ranger improved 4×4 engine , although they say same transmission and improved engine as Ranger in ads. Ford Buit Tought? MY2022! PLEASE INVESTIGATE THIS HIGHWAY TRAFFIC SAFETY ISDUE. NO BRAKING NOR STEERING…”

“MY STEERING COLUMN BROKE RIGHT OFF! TRYING TO PUT IT IN DRIVE @99,735 MI. HAD TO TOW IT TO SHOP, AND REPLACE THE STEERING COLUMN. I SEE OTHER PEOPLE HAD THIS SAME PROBLEM. THERE SHOULD BE A RECALL FOR THIS!!! I ALSO HAD TO REPLACE THE TRANSMISSION @ 103,000 MILES IT WOULD SKIP 3RD GEAR. SEEMS EVERYONE ELSE HAS TO REPLACE THE TRANSMISSION. ALSO BACK BEARINGS!! WHAT A DISGRACE. RECALL THIS DISGRACEFUL WORKMANSHIP! NO HONOR!”

“TL* THE CONTACT OWNED A 2004 FORD EXPLORER SPORT TRAC. WHILE DRIVING 40 MPH IN INCLEMENT WEATHER AND ROAD CONDITIONS, THERE WAS A LOSS OF TRACTION AND STEERING ABILITY. THE VEHICLE SPUN OUT OF CONTROL, ROLLED OVER AT LEAST FIVE TIMES, AND CRASHED INTO A DITCH. THE SEAT BELT RESTRAINED THE DRIVER; HOWEVER, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED EXTENSIVE BRUISING ON THE RIGHT SIDE OF THE BODY, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. MILLER MOTOR SALES INC (1196 MILWAUKEE AVE, BURLINGTON, WI 53105, (888) 449-0974) WAS NOTIFIED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED AND TOWED TO A YARD BY THE INSURANCE COMPANY. THE APPROXIMATE FAILURE MILEAGE WAS 204,000.”

“IN 2004 FORD EXPLORER WITH V8, THE CRUISE CONTROL TURNS OFF ENGINE WHEN TRAVELING 35~45 MPH AND GOING DOWN A HILL OR DECLINE. THIS AFFECTS POWER STEERING AND BRAKES MAKING IT DIFFICULT TO CONTROL AND SLOW DOWN THE VEHICLE. THIS HAS HAPPENED REPEATEDLY FOR THE PAST 10 YEARS, SO I AM USED TO THIS DEFECT. MY WORKAROUND IS TO PUT THE VEHICLE IN NEUTRAL AND RESTART THE VEHICLE AND THEN CONTINUE.”

“ALL FOUR SEALS WHERE LEAKING INCLUDING PINION SEALS. CLUNKING NOISE 40 TO 50MPH WHEN YOU LET GO OF THE GAS ,HOLDS BACK,HEATER GAUGE+MPH GAUGE DON'T WORK MOST.OF THE TIME.PAINT CHIPPING AWAY ALL OVER.REPLACED ALL SEALS 5 TIMES +YOKE CVHALF SHAFT. REPLACED FRONT DIFFERENTIAL STILL MAKING THE NOISE.POOR LIGHTING AT NIGHT.IT HAS A MISS FIRE GAVE IT A TUNEUP AND STILL IS DOING IT. RADIO VOLUME WON'T TURN DOWN IT GOES LOUDER WHEN TURNING DOWN.”

“THE CAR WAS RUNNING FINE AND NO WARNING LIGHT OF ANY KIND CAME ON. WE WENT TO GO START IT TODAY AND IT START UP FINE. WHEN WE TRIED TO PUT IT IN ALL THE GEARS AND PRESSING ON THE GAS IT DIDN'T DO A THING. I MEAN IT WON'T MOVE AT ALL.”