200 owner complaints to NHTSA about the 1997 Ford Explorer cite vehicle speed control, 11% of all 1,789 complaints for this model year. NHTSA also lists 4 recalls on this component.
“TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ACCELERATOR PEDAL BECAME DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 215,000.”
“TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH ON A STEEP UPHILL GRADE, THE BRACKET THAT SUPPORTED THE GAS PEDAL SUDDENLY BROKE AWAY FROM THE FIREWALL AND THE BRACKET AND GAS PEDAL SLID INTO THE FLOOR BOARD AND UNDER THE SEAT. THE VEHICLE WAS BACKED DOWN THE HILL IN NEUTRAL AND MANEUVERED TO THE SIDE OF THE ROAD IN LIGHT ONCOMING TRAFFIC. ASSISTANCE WAS SUMMONED AND UPON INSPECTION THE GAS PEDAL WAS FOUND WITH THE BRACKET THAT ATTACHED TO THE FIREWALL IN A NEW LIKE CONDITION, EXCEPT WHERE THREE SPOT WELDS ATTACHED TO THE GAS PEDAL BRACKET TO THE FIREWALL HAD BROKEN AWAY. THE VEHICLE WAS RIGGED TO A RUNNING CONDITION TO TRAVEL APPROXIMATELY TWO MILES OR LESS TO THE OWNERS RESIDENCE WHERE A MORE RELIABLE REPAIR WAS MADE. THE REPAIR WAS OVER SEEN BY A LICENSED A&P MECHANIC. THE MANUFACTURER WAS NOTIFIED BY THE OWNER OF THE WELD FAILURE. THE APPROXIMATE MILEAGE WAS WELL OVER 100,00 AND IS CURRENTLY BACK IN SERVICE. UPDATED 06/18/13*LJ”
“WE WERE LUCKY THIS TIME, WE HAD THE EXPLORER IN THE SHOP AND I GOT A CALL FROM THE LEAD TECH THAT STATED WHILE THE WERE SERVICING THE BRAKES NO LESS THAN 3 LINES ROTTED THROUGH, BUT*** THE ANTILOCK CONTROLLER SPRUNG A LEAK AND SPRAYED FLUID ALL OVER THE HOT ENGINE CAUSING A SMALL FIRE!!! NO DAMAGE BUT WE WERE LUCKY... *TR”
“TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT AS SOON AS THE VEHICLE WAS STARTED, IT ACCELERATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE SPEED CONTROL DEACTIVATION SWITCH HAD BEGAN TO LEAK INTERNALLY AND CAUSED THE FAILURE. THE CONTACT WAS INFORMED OF A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) HOWEVER, THE DEALER INFORMED HIM THAT THEY WERE ONLY REQUIRED TO STOP THE LEAK BUT NOT REPLACE THE DEFECTIVE PART. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 201,000. UPDATED 01/05/13*LJ UPDATED 2/13/2013 *JS”
“TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT WHILE TRYING TO ACCELERATE, THE VEHICLE WOULD NOT RESPOND UNLESS AN EXCESSIVE AMOUNT OF PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE THROTTLE BODY HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V422000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 170,000.”
“TL* THE CONTACT OWNS A 1997 FORD EXPLORER EDDIE BAUER EDITION. THE CONTACT STATED THAT WHILE ACCELERATING FROM A DRIVING TRAFFIC STOP, THE ENGINE GROWLED LOUDLY AS THE VEHICLE ABNORMALLY ACCELERATED RAPIDLY. THE BRAKES WERE ENGAGED AND THE VEHICLE CAME TO A STOP. THE CONTACT WAS ABLE TO RESUME AS NORMAL. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS BUT THEY WERE UNABLE TO LOCATE A DEFECT. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.”
Showing 6 of 200 reports. Read every report on NHTSA.gov.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES AND STILL RETAIN THE ORIGINAL THROTTLE BODY (PART NUMBERS 97JF-9E926AB OR 97JF-9E926-AC). SOME OF THE ORIGINAL THROTTLE BODIES INSTALLED ALLOWED A GAP BETWEEN THE PLATE AND BORE TO BE BUILT TOO NARROW. THIS REDUCED CLEARANCE ALLOWED THE ENGINE DEPOSITS NORMALLY PRESENT IN THE THROTTLE BODY TO CONTACT OR BRIDGE THE GAP. IF THE ENGINE DEPOSITS BRIDGED THE GAP BETWEEN THE THROTTLE PLATE AND BORE AND THEN HARDENED, ON THE INITIAL APPLICATION OF THE ACCELERATOR PEDAL AFTER THE ENGINE HAS COOLED, THE OPERATOR WOULD NEED TO APPLY ADDITIONAL FORCE TO THE ACCELERATOR PEDAL TO BREAK THE BRIDGE.
VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.