2000 Ford Explorer engine and engine cooling problems

“2000 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO RECALL STATES ENGINE RUNNING WITHOUT IGNITION KEY COULD START A FIRE. CONSUMER STATES THOUGHT DEALERSHIP REPAIRED RECALL PROBLEMS. VEHICLE EXPLODED SEVEN MINUTES AFTER CONSUMER EXISTS VEHICLE. *SMD”

“TL* THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT WAS DRIVING 35 MPH WHEN SMOKE EMITTED FROM THE REAR END OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND NOTICED FLAMES COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS DESTROYED. THE POLICE AND THE FIRE DEPARTMENT WERE CONTACTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 179,000.”

“SPARKPLUG SUPER-HEATED AND MELTED LONGITUDINALLY DESTROYING THE OUTERMOST SPARKPLUG THREADS (7 THROUGH THE SEATING SURFACE OF THE SPARK PLUG). INNER MOST THREADS, THE ONES DEEPEST INTO THE HEAD WERE NOT DAMAGED. A SECOND PLUG WAS INSTALLED ALONG WITH A NEW SPARK PLUG WIRE AND WITHIN 20 MILES, THE SPARKPLUG WAS AGAIN MELTED BEYOND SALVAGE AND THE NEW WIRE BURNED UP. DUE TO THE DESTRUCTION OF THE SPARKPLUG, IT WAS ABLE TO BE REMOVED WITHOUT TOOLS AS THERE WERE NO THREADS REMAINING IN THE CYLINDER HEAD. FORTUNATELY THE FIRE DAMAGE (LIKELY FROM THE SPARK OF THE PLUG) WAS LIMITED ONLY TO DAMAGING THE SPARKPLUG AND THE SPARK PLUG WIRE LABLED #3. *TT”

“THIS IS TO REPORT A FIRE IN A 2000 FORD EXPLORER: ON FRIDAY, 25 NOV 11, 5 ADULTS (MY HUSBAND, 2 SONS, DAUGHTER-IN LAW, AND MYSELF) AND 2 DOGS, LEFT BETHLEHEM PA FOR OUR FAMILY CHRISTMAS TRIP IN OUR 2000 FORD EXPLORER, PULLING A UTILITY TRAILER. THE INTENT OF THE TRIP WAS TO START AT A CHRISTMAS TREE FARM, CUT DOWN 3 CHRISTMAS TREES, HAUL THEM IN THE TRAILER AND CONTINUE WITH SEVERAL OTHER CHRISTMAS RELATED TRADITIONAL STOPS. MY HUSBAND, DROVE APPROXIMATELY 45 MINUTES NORTH TO BISSELS CHRISTMAS TREE HILL IN LEHIGHTON, PA. HE DID NOT USE CRUISE CONTROL BECAUSE WE WERE PULLING THE TRAILER. THE TRIP WAS FINE WITH ABSOLUTELY NO INDICATIONS THAT ANYTHING WAS WRONG WITH THE VEHICLE. IT ALSO HAD NOT HAD ANY SERVICE DONE TO IT RECENTLY (A QUESTION FREQUENTLY ASKED TO US). HE PARKED THE VEHICLE ALONG AN EMBANKMENT AT THE TREE FARM AND WE ALL WERE IN VARIOUS STAGES OF GETTING OUT OF THE CAR WITH THE DOGS WHEN SOMEONE NEARBY YELLED TO US THAT OUR CAR WAS ON FIRE. SHE REPEATED IT AS WE LOOKED TO SEE WHO SHE WAS ADDRESSING. WE LOOKED AT OUR CAR AND SAW THAT UNDER IT, FIRE BALLS WERE HITTING THE GROUND FROM WHAT APPEARED TO BE THE CENTER OF THE ENGINE. MY HUSBAND ATTEMPTED TO…”

“THE 2000 FORD EXPLORER SUV BEGAN TO SLOW DOWN AS THE ENGINE RPMS INCREASED. AFTER PULLING OVER AND TURNING THE IGNITION OFF, WE NOTICED SMOKE COMING FROM THE HOOD. UNDERNEATH THE CAR, FLAMES WERE DRIPPING DOWN FROM THE TRANSMISSION. WE USED A FIRE EXTINGUISHER TO EXTINGUISH THE FLAMES ON THE GROUND, AND ATTEMPTED TO OPEN THE HOOD. AFTER THE HOOD WAS OPENED, LARGE FLAMES WERE OBSERVED IN THE ENGINE COMPARTMENT. THE FIRE EXTINGUISHER WAS USED UNTIL EMPTY AND HAD LITTLE IMPACT. THE CAR BEGAN TO BURN QUICKLY AND THE FLAMES SPREAD FROM FRONT TO BACK. THE EMERGENCY SERVICES ARRIVED, EXTINGUISHED THE FIRE AND COLLECTED WITNESS STATEMENTS. NO ONE WAS HURT IN THE INCIDENT AND THE FRAME WAS TOWED VIA AAA TO A NEARBY AUTOMOTIVE SHOP. *KB”

“MY FORD EXPLORER CAUGHT ON FIRE. ALL I SAW WAS CLOUD OF SMOKE. THEN PEOPLE STARTED YELLING AND BLOWING THEIR HORN AT ME, THE UNBELIEVABLE, THAT MY CAR WAS ON FIRE. *TR”