2001 Ford Explorer service brakes, hydraulic problems

“WHILE DRIVING ON A HEAVILY TRAVELED ROAD, DRIVER 2 CARS AHEAD OF ME CAME TO A DEAD STOP. VEHICLE IN FRONT OF ME HIT BRAKES HARD, I ALSO HIT MY BRAKES HARD, ON WET PAVEMENT. THE ANTI-LOCK BRAKE SYSTEM DID NOT KICK IN, AND THE BRAKES LOCKED UP.MY CAR SLID INTO THE REAR END OF DRIVER IN FRONT OF ME DOING EXTENSIVE DAMAGE TO THE FRONT END OF MY VEHICLE. AS I HAD JUST COME THROUGH A TRAFFIC LIGHT, I WAS NOT GOING MORE THAN ABOUT 25 MILES PER HOUR. THE WET PAVEMENT CAUSED MY CAR TO SKID QUITE A WAYS. THE DAMAGE TO MY VEHICLE INCLUDED THE ENTIRE BUMPER COVER BUCKLING, BOTH OF MY HEADLIGHTS AND TURN SIGNALS WERE DAMAGED AND BROKEN OUT. NONE OF THE COMPONENTS WERE PUSHED BACK INTO THE ENGINE COMPARTMENT. NEITHER THE DRIVER SIDE OR PASSENGER SIDE FRONT AIR BAGS DEPLOYED. MY PASSENGER WAS JOLTED FORWARD AND ALMOST HIT THE WINDSHIELD DESPITE HAVING SEAT BELT ON. I WAS JOLTED FORWARD AS WELL WITH SEAT BELT ON, AND MY CHEST HIT THE STEERING WHEEL.”

“BRAKES, ROTORS, PADS, ARE NEW... THE EXPLORER SPORT STILL DOES NOT COME TO A FULL STOP ... (2001) MILES 4900, BRAKES GO TO THE FLOOR AND KEEPS GOING 2 TO THREE FEET MORE BEFORE IT STOPS... *TR”

“TL* THE CONTACT OWNS A 2001 FORD EXPLORER SPORT. THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH, ATTEMPTING TO MAKE A LEFT TURN. THE BRAKE PEDAL TRAVELED TO THE FLOOR WHEN ENGAGED, AND THE VEHICLE SURGED FORWARD WITHOUT WARNING. THE FAILURE OCCURRED MORE FREQUENTLY IN EXTREMELY WARM WEATHER TEMPERATURES WHEN MAKING A LEFT TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY INFORMED THAT THE ANTI-LOCK BRAKE SYSTEM WAS POSITIONED CLOSE TO THE ENGINE WHICH CAUSED THE ABS TO OVERHEAT AND CONTRIBUTED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN.”

“I HAVE A 2001 FORD EXPLORER SPORT. AFTER DRIVING FOR ANY PERIOD OF TIME,(ESPECIALLY AT HIGHWAY SPEEDS) WHEN YOU APPLY THE BRAKES THEY SHUDDER VIOLENTLY. AS YOU TRY TO COME TO A STOP AT ANY TIME THE BRAKES GO IN ANTI- LOCK MODE AND THEN GIVE OUT!! YOU HAVE TO PUMP THE BRAKES TO GET THEM TO HOLD. IT IS VERY SCARY AND DANGEROUS SITUATION. I HAD THE BRAKES REPAIRED AT MY FORD DEALER (FETTE FORD, CLIFTON NJ) NOT THAT MANY MILES AGO. AND THEY TELL YOU THEY HAVE NEVER HEARD OF THIS PROBLEM BEFORE AND IT'S MY BAD DRIVING HABITS CAUSING THE PROBLEM. THERE IS A WEBSITE (FORDBRAKES.COM) WHERE HUNDREDS OF DRIVERS DESCRIBE THE SAME PROBLEMS AND SIMILAR LIES TOLD TO THEM BY FORD SERVICE DEPTS. WHEN THIS STORY FINALLY GETS OUT AND WE START REALIZING HOW MANY ACCIDENTS, INJURIES, AND MAYBE DEATHS HAVE OCCURRED OVER THE PAST DOZEN YEARS. IT WILL PROBABLY RIVAL THE TOYOTA COVER-UP. PLEASE TAKE ACTION AND INVESTIGATE NOW!!! *TR”

“FRONT BRAKE ROTORS WARP AND BRAKES ARE BAD WITHIN 13,000 MILES. PROBLEM HAS RECURRED SEVERAL TIMES. APPARENTLY THE BRAKES FOR THE HEAVIER FORD SPORT TRAC MODEL ARE FROM THE LIGHTER FORD RANGER AND UNDERSIZED. BRAKES FAILING ON THIS SHORT INTERVAL COULD LEAD TO DRIVERS ON THE ROAD WITH TOTALLY INADEQUATE BRAKING CAPACITY. *TR”

“2001 FORD EXPLORER SPORT - INTERMITTENT LOCKING OF THE BRAKES WHICH CAUSES THE VEHICLE TO PULL HARD TO THE LEFT, CREATING AN UNCONTROLLABLE VEHICLE. THIS INTERMITTENT LOCKING CAN OCCUR AT ANY SPEED INCLUDING HIGHWAY SPEEDS, WHICH IS OBVIOUSLY VERY DANGEROUS. VEHICLE CAN NOT BE SOLD AS IT IS UNSAFE TO DRIVE, FORD MOTOR COMPANY DOES NOT KNOW HOW TO FIX THE VEHICLE. SEPTEMBER 2004 - 30,173 MILES. CUSTOMER STATES VEHICLE PULLS TO THE LEFT WHEN BRAKING. TECHNICIAN COULDN'T DUPLICATE PROBLEM. OCTOBER 2004 - 30,400 MILES. CUSTOMER STATES VEHICLE IS PULLING HARD TO LEFT WHEN BRAKING AT TIMES. TECHNICIAN COMMENTS "FOUND VEHICLE PULLING TO LEFT AND FELT POP IN PEDAL AND VEH STARTED BRAKING STRAIGHT, CHECKED BRAKES FOUND RIGHT INNER BRAKE PAD STUCK TRIED TO REPLACE BRAKE HARDWARE. REPLACED PADS TO GET HARDWARE KIT INSTALLED HARDWARE KIT AND NEW PADS AGAIN DROVE THE VEHICLE VEHICLE FOUND VEHICLE STOPS STRAIGHT." NOVEMBER 1, 2004 - CUSTOMER STATED THAT VEHICLE PULL HARD TO THE LEFT WHEN BRAKING AT TIMES SERVICE COMPLETED BRAKE SERVICE - CALIPER ASY - BRAKE - LESS PAD - FLUID BRAKE - HUB ASY - WHEEL NOVEMBER 8, 2004 - 31,311 MILES. - CUSTOMER STATED BRAKES PULL TO THE LEFT…”