2007 Ford Explorer power train problems

“The contact owns a 2007 Ford Explorer. The contact stated while starting the vehicle, the contact became aware of a failure with the transmission. The contact attempted to shift the gear shifter and the vehicle made a loud clanking sound and the vehicle was rattling. There were no warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed as a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 150,076.”

“WHILE DRIVING ON THE THE HIGHWAY ON RAMP THE VEHICLE WAS HARD TO ACCELERATE AND ALMOST CAUSED AN ACCIDENT MERGING ON THE HIGHWAY. WHEN THE VEHICLE WAS SCANNED 16 TRANSMISSION OBD CODES CAME UP. THE CAUSE OF THE CODES WAS A CORRODED CONNECTOR GOING TO THE TRANSMISSION. IT CORRODED FROM WATER INTRUSION FROM WATER LEAKING FROM THE A/C DRAIN ONTO THE TRANSMISSION ELECTRICAL CONNECTOR. THIS IS A SAFETY ISSUE THAT NEEDS TO GET FIXED AND PAID BY FORD FOR POOR ENGINEERING.”

“OUT TRANSMISSION FAILED WHILE DRIVING DOWN THE ROAD. WE UNDERSTAND THAT THIS PROBLEM HAS BEEN REPORTED MANY TIMES AND THAT FORD IS AWARE OF IT. IT IS A MALFUNCTION IN THE TRANSMISSION AND NOT A MAINTENANCE PROBLEM. WE WERE DRIVING ON 25 HEADED EAST OUT OF BAY CITY GOING STRAIGHT AT 55 MILES AN HOUR.”

“TL* THE CONTACT DRIVES A 2007 FORD EXPLORER OWNED BY THE PHILADELPHIA SCHOOL DISTRICT. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE HESITATED WHILE DEPRESSING THE ACCELERATOR PEDAL. THE CONTACT STATED THAT THE TRANSMISSION AND ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT ALSO STATED THAT THE PASSENGER SIDE MIRROR WAS DETACHED AND WAS RE-ATTACHED WITH A PIECE OF GLASS AND TAPE. THE CONTACT STATED THAT THE FAILURES WERE REPORTED TO THE SUPERVISOR AS WELL AS DOCUMENTED IN A VEHICLE REPORT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR REPAIRS, BUT THE FAILURE PERSISTED. THE CONTACT ALSO STATED THAT SEVERAL OTHER FORD EXPLORERS IN THE PHILADELPHIA SCHOOL DISTRICT FLEET WERE UNSAFE TO DRIVE AS THEY EXHIBITED HESITATION AND STALLING. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURES. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE FAILURE MILEAGE WAS UNKNOWN.”

“TL* THE CONTACT OWNS A 2007 FORD EXPLODER. THE CONTACT STATED THAT THE TRANSMISSION HAD CRACKED. THE CONTACT CALLED FORMULA FORD LOCATED AT 4318 MIDDLE RUTLAND VT 05701 800-906-6065. THE VEHICLE WAS NOT REPAIRED. IT WAS UNKNOWN IF THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 130,000.”

“TL* THE CONTACT OWNS A 2007 FORD EXPLORER. WHEN THE VEHICLE WAS BEING INSPECTED, THE MECHANIC STATED THAT THE DRIVE SHAFT BEARINGS WERE LOOSE AND SLIGHTLY DETACHED. THE MECHANIC DIAGNOSED THAT THE DRIVE SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS A BACKORDER ON THE DRIVE SHAFTS. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.”