1997 Ford F-150 suspension problems

“WHILE DRIVING DOWN THE ROAD AT 35 MPH WITH NO LOAD AND NOTHING IN TOW THE SUB-FRAME CRACKED ON BOTH THE DRIVER AND PASSENGER SIDE. ON THE DRIVER SIDE IT CRACKED BEHIND THE REAR TIRE. ON THE PASSENGER SIDE IT CRACKED IN FRONT OF THE REAR TIRE. THE VEHICLE BOWED AND SMASHED THE TOP OF THE BED INTO THE BACK OF THE CAB. MECHANIC ADVISED THE FRAME DETERIORATED AND COST OF FRAME REPLACEMENT WOULD EXCEED THE REPLACEMENT OF THE VEHICLE.”

“WHILE DRIVEING AT 60 MPH THERE WAS A LOUD CRASH FROM THE LEFT REAR THEN A GRINDING POP FROM THE LEFT REAR ALL WHILE THE REAR END OF MY TRUCK FELT LIKE IT WAS FISH TAILING ON ICE OR LIKE SOME ONE HUGE WAS SHAKEING IT FROM SIDE TO SIDE I ALMOST LOST IT INTO A FIELD I WAS SO SUPRISED I GOT STOPPED TO LOOK THE LEFT REAR SHACKLE CUT LOOSE BECAUSE IT WAS ALMOST ALL DOTTED AWAY THE LOWER SPRINGS ON BOTH SIDES ARE MISS ALIGNED BY 2 INCHES EACH AND THE SPRING END IS NOW PEEKING THRU THE BED THIS TRUCK WAS BOUGHT BRAND NEW BY MY BEST FRIENDS DAD AND WAS WELL TAKEN CARE OF KEPT IN THE GARAGE AND NOT USED TO TOW OR HAUL BUT IT IS RUSTING AWAY SO BADLY THAT THE EXHAUST BOLTS HAVE ROTTED AWAY ON BOTH SIDES AND WILL COST 1500 TO FIX ALOT OF THAT IS THE COST TO GET THE BOLTS OUT OF THE EXHAUST MANIFOLD THEY SAY BUILT FORD TOUGH BUT THEY REALY MEEN FORD BUILT IT AND IF U GET IT WET TOUGH ITS GONA ROT AWAY !”

“I WAS DRIVING HOME FROM TOWN WHEN ALL THE BALL BEARINGS FELL OUT OF THE STEERING COLUMN AND THE STEERING WHEEL BECAME LOOSE AND THE TRUCK BEGAN TO SWAY FROM RIGHT TO LEFT, IT WAS CONTROLLABLE AT THE LOW SPEED I WAS GOING BUT THANK GOD I WASN'T ON AN INTERSTATE OR HIGHWAY AT A HIGHER SPEED I COULD HAVE RUN OFF THE ROAD OR WORSE HAD A HEAD ON COLLISION ! THE TRUCK HAS NOT LEFT MY PROPERTY SINCE BUT I STILL HAVE TO KEEP FULL COVERAGE INSURANCE AND TAGGED FOR INSURANCE PURPOSES AND A LIEN FROM MY BANK ON IT,I HAVE ALSO REPLACED THE STARTER ON IT EIGHT (8) TIMES THE PARTS ARE VERY CHEAP BUT IT HAS AN AIRBAG AND MY LOCAL FORD DEALER GAVE ME AN ESTIMATE OF 200.00 TWO HUNDRED DOLLARS TO REPLACE TWO SIX AND SEVEN DOLLAR BEARINGS. WHEN THE INCIDENT HAPPENED I HAD NO IDEA WHAT HAPPENED SINCE THE BALL BEARINGS ARE VERY TINY AND ARE HARD TO SEE AND IT TOOK A LONG TIME TO FIGURE OUT WHAT HAPPENED MY TRUCK JUST SITS THERE ALL THIS TIME BECAUSE IM AFRAID OF SOMEONE GETTING HURT SERIOUSLY OR KILLED BECAUSE IM AFRAID OF LOSING CONTROL ON THE STEERING. I HAVE BEEN DRIVING SINCE I WAS SIXTEEN AND WAS A BIG TRUCK DRIVER FROM 1979 TO 1996 TILL I BECAME ILL BUT I WOULD NEVER DRIVE A…”

“REAR SPRINGS, REAR BUCKLE REAR SPRINGS WERE COMPLETELY RUSTED THROUGH. GARAGE THAT REPAIRED THE ITEMS INDICATED THAT THEY HAVE FIXED A VERY LARGE AMOUNT OF FORD TRUCKS WITH THE SAME ISSUES. THIS SEEMS TO BE AN ISSUE THAT WARRANTS SOME INVESTIGATION. NOTE THAT THE TRUCK GASOLINE TANKS ALSO RUSTED THROUGH, FAILED AND RESULTED IN THE TANK FALLING OUT OF THE TRUCK WHILE UNDERWAY. THIS WAS FIXED, ALBIET AFTER 3 YEARS, BY A FORD RECALL THAT WAS INITIATED THIS YEAR. *TR”

“TL*THE CONTACT OWNS A 1997 FORD F-150. WHILE DRIVING OVER A BUMP AT 30 MPH, THE CONTACT HEARD A LOUD NOISE AND NOTICED THAT THE REAR DRIVER'S SIDE COIL SPRING FAILED AND WAS STRIKING AGAINST THE TIRE. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 98V161000 (SUSPENSION: REAR: SPRINGS: LEAF SPRING ASSEMBLY). IF THE CONTACT REPAIRS THE VEHICLE, THE MANUFACTURER WILL OFFER A TWO MONTH WARRANTY FOR THE REAR SPRING. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND CURRENT MILEAGE WAS 126,000. UPDATED 06/12/09 *BF UPDATED 06/16/09”

“1) DRIVING LOW SPEED RESIDENTIAL 2) MIDDLE LEAF SPRING REAR DRIVER SIDE BROKE, MOVED FORWARD OVER TIME AND SWUNG INTO TIRE SIDE WALL DESTROYING TIRE. RECALL NHTSA # 98V161000 HAD BEEN PERFORMED IN 1998 TO CORRECT THIS POTENTIAL FAILURE. FURTHER INSPECTION REVEALED THE OPPOSITE SIDE LEAF SPRING IS BROKEN AND COULD DO THE SAME THING OR PUNCTURE THE FUEL TANK. 3) BOTH REAR LEAF SPRING SETS NEED REPLACEMENT AND LEFT REAR TIRE NEEDS REPLACEMENT. *TR”