2003 Ford F-150 engine problems

“I moved my vehicle from driveway to park on the street so my husband could park in the driveway. I then turned my vehicle off and roughly 2 hours later, a lady came screaming "fire fire fire!" I went to see where she was talking about and my truck was smoking under the hood, I then called the fire department and they came to extinguish the fire. I was unaware of any recalls as I am the 3rd owner of this vehicle.”

“On 11/27/2022 at or around 4:30 P.M. my 2003 Ford F-150 burned almost completely, without any mechanical failures or warnings, thirty full minutes after being parked and then after only having been run for three to four miles. The fire department ended up putting it out before it was fully consumed.”

“TL* THE CONTACT'S BOYFRIEND OWNS A 2003 FORD F-150. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE IGNITION COILS AND ALL SPARK PLUGS WOULD BLOW OUT INSIDE OF THE ENGINE WHICH WOULD CAUSE THE VEHICLE TO STALL AS THE CHECK ENGINE LIGHT WOULD APPEAR ON THE DASHBOARD. THE CONTACT STATED THAT SHE HAS HAD THE IGNITION COILS AND SPARKS PLUGS REPLACED ON FOUR SEPARATE OCCASIONS ALL BY INDEPENDENT MECHANICS HOWEVER, THE FAILURE PERSISTED. THE CONTACT ALSO CALLED THREE SEPARATE DEALERS BUT WAS UNABLE TO REACH A SERVICE REPRESENTATIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. SHE WAS REFERRED TO NHTSA FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.”

“TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE FROM DRIVING, THE VEHICLE BEGAN TO SMOKE FROM THE DRIVER'S SIDE OF THE VEHICLE. THE CONTACT STATED THAT SHORTLY AFTER THE VEHICLE CAUGHT ON FIRE UNDER THE HOOD ON THE DRIVER'S SIDE. THE FIRE DEPARTMENT CAME TO PUT OUT THE FIRE AND FILED A POLICE REPORT. THE VEHICLE WAS TOWED AND DEEMED TOTALED. THE CONTACT HAD CONTACTED THE DEALERSHIP (SAM PACK'S FIVE STAR FORD ADDRESS: 1635 S INTERSTATE 35E, CARROLLTON, TX 75006 PHONE: (972) 446-5027) WHO INFORMED THAT THERE WAS NO RECALL ON THEIR VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 240,000.”

“TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT HAD BEEN ILLUMINATED SINCE THE DAY OF PURCHASE. THE CONTACT ALSO STATED THAT WHILE THE VEHICLE WAS PARKED IN THE CAR PORT THE VEHICLE SUDDENLY CAUGHT ON FIRE. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. A FIRE DEPARTMENT REPORT WAS MADE. THE VEHICLE WAS DEEMED TOTALED AS WELL AS DAMAGED THE CONTACT'S RESIDENCE. THERE WERE NO INJURIES. THE CONTACT CONTACTED A CERTIFIED MECHANIC WHO INFORMED THEM OF A RECALL FOR THE YEAR/MAKE/MODEL, NHTSA CAMPAIGN NUMBER: 06E056000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THE VIN HAD NOT SHOWN TO BE INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 203,000. *BF *DL”

“TL* THE CONTACT OWNED A 2003 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL) AND A REPAIR APPOINTMENT WAS SCHEDULED WITH THE LOCAL DEALER. THE CONTACT STATED THAT HE WAS NOT INFORMED BY THE DEALER THAT THE DEFECTIVE PART COULD HAVE BEEN DISCONNECTED FROM THE VEHICLE TO AVOID A FIRE WHICH WAS STATED IN THE RECALL REMEDY. THE CONTACT STATED AFTER HIS GIRLFRIEND PARKED THE VEHICLE, ABOUT FOUR AND A HALF HOURS LATER THE VEHICLE UNEXPECTEDLY WAS ENGULFED IN FLAMES FROM THE ENGINE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FLAMES. A FIRE DEPARTMENT REPORT WAS FILED. THE CONTACT STATED THAT TWO OTHER VEHICLES WERE DAMAGED BY THE FIRE. THE DEALER WAS NOTIFIED OF THE INCIDENT AND CANCELED A SCHEDULED APPOINTMENT HOWEVER THE MANUFACTURER WAS NOT MADE AWARE OF THE INCIDENT. THE FIRE DEPARTMENT DEEMED THE VEHICLE A TOTAL LOSS. THE FAILURE MILEAGE WAS 196,000.”