2005 Ford F-150 suspension problems

“Frame on passenger and drive side by transmission, fuel tank, and rear leaf springs are rusted and have no integrity left. No structure integrity if in an accident. If fractures completely, will loose control of vehicle as the bed will contact cab, driveshaft will jamb into transmission, lock up brakes from pinched brake lines, loss of brakes from severed brake lines, lose control and go into on coming traffic or into roadside structures including pedestrians. NOTE: Your system will not let me upload pictures.”

“The undercarriage and frame is rusted .Ford said it was not under warranty and the truck was unsafe to drive. Most of the rust is mainly at the rear of truck and if the truck was hit in the rear it would be very unsafe to drive.”

“The contact owns a 2005 Ford F-150. The contact stated that while driving and making a turn at various speeds, there was an abnormal popping noise detected. There were no warning lights illuminated. The contact stated that the spark plugs, cam shaft sensor, and coils were replaced. The vehicle was taken to the local dealer where it was diagnosed that the CV axle boots were torn. The vehicle was repaired but the failure persisted. The manufacturer was contacted and the contact was referred to the NHTSA hotline. The approximate failure mileage 91,082.”

“The main frame is so corroded that it is unsafe to drive. The body has no rust and the engine only has 73,000 miles on it. I went to the Ford garage for new tires and they found the damage to the frame”

“This is the 2nd Ford F 150 pick up with which I've had rusted frames! The 1st, a 1999, I ended up junking. This one needs $2000 of welding to make the frame safe to drive. The proprietor of [XXX] Welding says he's done over 40 F 150's for the same problem with the frames. My mechanic, [XXX], at Shaw's Automotive, says he's seen F 150's that have collapsed around a lift when they were in for a simple oil change. The internet states this is a common issue with F 150's. SAFETY, SAFETY, SAFETY! These trucks should not be on the road until Ford repairs them or buys them back, like Toyota did in the 90's!!!!”

“FRAME RUSTING TERRIBLY AND FRAME CRACKING NEAR DRIVERS SIDE FORWARD LEAF SPRING MOUNT. TRUCK HAS ONLY 128,000 MILES. DO NOT HAUL OR TOW ANY WHERE NEAR THE TRUCKS CAPACITY. NORMAL DRIVING AND MINOR OFF ROAD USE.”