2006 Ford F-150 suspension problems

“FRAME IS COMPLETLY RUSTED THROUGH AND EVERY F-150 IN THIS YEAR RANGE HAS THE SAME PROBLEM. HUGE SAFTY RISK TO ALL. TOYOTA HAD THE SAME PROBLEM AND WARRANTIED THEM ALL THIS IS NOT SAFE AT ALL”

“I JUST HAD MY TRUCK SERVICED AT SAYVILLE FORD & THEY FOUND TWO BROKEN FRONT SPRINGS. THE TRUCK HAS 142000 MILES. I CANT FIND ANY RECALL INFO ON NHTSA. CAN YOU ADVISE ME IF THIS IS A CURRENT PROBLEM BEING INVESTIGATED?”

“TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THE DRIVE SHAFT SEPARATED FROM THE VEHICLE. THE CONTACT WHO WAS A CERTIFIED MECHANIC REPAIRED THE REAR AXLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.”

“SHUTTERS UPON ACCEL. REAR CLUTCH PATCH REPLACED. RETURNED 04/28/2014 FOR SAME PROBLEM. THE 3RD TIME I RETURNED ON 05/29/2014. AGAIN THE SHUTTERING CONTINUES..THIS PROBLEM WAS SINCE BEEN FIXED. HOPEFULLY. *TR”

“THE FRAME BROKE WHERE THE FRONT DIFFERENTIAL MOUNTS, THIS LET THE FRONT AXLE TWIST AND YOU CAN NOT STEER THE TRUCK!!! I THINK THIS IS VERY DANGEROUS, IF YOU WERE GOING OVER 5 MPH. YOU COULD NOT TURN.FORD FACTORY REP. SAYS THE TRUCK IS OUT OF WARRANTY SO NOT THERE PROBLEM, THEY WILL NOT DO ANYTHING ABOUT IT. FORD SHOULD FIX THIS AT THERE EXPENSE AS THIS A SAFETY CONCERN. HOW MANY OTHER FORD PICK UPS HAVE HAD THIS SAME PROBLEM BUT NOT REPORTED IT BECAUSE THEY DID NOT HOW TO OR WHO TO COMPLAIN TO. THE NTSB SHOULD LOOK INTO THIS VERY CAREFULLY TO SEE IF THIS IS A MAJOR PROBLEM. *TR”

“I HAD TO REPLACE ALL OF THE GEARS AND THE INSIDE AND OUTSIDE BEARINGS AND SEALS IN THE REAR END - ON A TRUCK THAT HAD 87,000 MILES. EVERY DEALERSHIP I'VE SPOKEN TO HAS TALKED ABOUT THE CHEAP BEARINGS IN THE FRONT AND REAR END ON THESE FORD F-150'S. 18,000 MILES AGO I HAD TO FIX THE FRONT END. *KB”