34 owner complaints to NHTSA about the 2009 Ford F-150 cite structure, 10% of all 324 complaints for this model year. NHTSA also lists 1 recall on this component.
“This vehicle has been a lemon ever since we purchased it new. To start the 3rd brake light would always leak during rain and ruined the headliner took it back to andy mohr ford were we purchased approx 25 times for this issue. Then we have had oil leaks about a year after purchase and it still leaks. Third the fender wells are rusting. And also all the lights on the dash are lit because the computer board failed. To date the truck only has 147k miles. This truck has been a lemon the whole time we have owned it and i am tired of sinking money in this junker. Ford needs to be held responsible for every vehicle off there assembly line.”
“Frame of the body is completely rusted through to the point that it is almost unsafe to drive. It was identified when attempting to replace the rocker panel on the passenger side and the list put a hole in the frame. The vehicle has been well maintained but the amount of rust seems unusual for the age of the vehicle. I know the previous owner and he took painstakingly good care of the vehicle and it has been driven very little since I purchased it a couple of years back. The fix is to repair the frame at the cost of $3k plus or let it rust away completely. The amount of rust does not add up and I see similar issues with thousands of comments online.”
“Door Striker Plate, latching Hook on Rocker Plate, lower side of driver side door frame, between front and rear doors is rusted. This does not allow the doors, front or rear driver side, to close securely. Attempted to contact Ford dealerships with no response. Took to independent Body Shop who said it is definitely a safety issue.”
“ACCELERATOR PEDAL SENSOR STICKS UNDER ACCELERATION. VERY DANGEROUS. IT'S HAPPEN 5 TIMES TO ME. 21,196 MILES ON THE TRUCK. I HOPE THIS TRUCK DOESN'T KILL NO ONE SOME DAY. I HAVE COPYED THIS PAGE FOR MY RECORDS AND SENDING COPIES TO THE PEOPLES LAWMAKERS STATE AND FED. THANK YOU FOR YOUR TIME. HAVE A GREAT DAY.”
“TL* THE CONTACT OWNS A 2009 FORD F-150. THE CONTACT NOTICED RUST ON THE BOTTOM CORNERS OF THE REAR DRIVER AND PASSENGER CREW CAB DOORS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A DRAIN TUBE CAME FROM THE SUN ROOF AND HAD NO WAY FOR THE WATER TO GET OUT. AS A RESULT, THERE WAS RUST AROUND THE LOWER FRONT STRIP OF THE DRIVER AND PASSENGER DOORS, AND THE BOTTOM TWO CORNERS OF THE REAR DRIVER AND PASSENGER DOORS NEEDED TO BE CUT OUT AND THE METAL RE-WELDED. THE VEHICLE WAS NOT REPAIRED. THE DEALER (KIP KILLMON FORD, 201 E MAIN ST, LOUISA, VA 23093 (540) 967-1350) WAS CONTACTED AND PROVIDED THE CONTACT NHTSA'S PHONE NUMBER. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND STATED THAT THERE WAS NO REMEDY FOR A VEHICLE OF THAT YEAR. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.”
“FIRST THE RIGHT REAR DOOR SHOWS THAT THE DOOR IS AJAR SO THE INTERIOR LIGHTS STAYS ON WHILE DRIVING FOR ABOUT TEN MILES BEFORE THEY GO OUT AND WHEN YOU STOP THE VEHICLE AND GET OUT THE LIGHTS STAY ON FOR ABOUT 20 MINUTES SO IT RUNS THE BATTERY DOWN. SECOND THING IS THE DRIVERS DOOR HANDLE DON'T RETURN TO THE CLOSED POSITION IT STAYS HALF WAY OUT AND A PIECE OF PLASTIC FELL OUT OF DOOR HANDLE I CONTACTED THE FORD COMPANY ABOUT THESE PROBLEMS AND I WAS TOLD THAT THEY WERE NOTHING THEY COULD DO ABOUT THE PROBLEMS. I MYSELF THINK THAT THESE PROBLEMS ARE A SAFETY PROBLEM AND VERY AGGRAVATING”
Showing 6 of 34 reports. Read every report on NHTSA.gov.
FORD IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 F-150 VEHICLES MANUFACTURED FROM JANUARY 18, 2008, THROUGH NOVEMBER 30, 2009. THE INTERIOR DOOR HANDLE HOUSING EMBOSSMENT RETAINING THE INTERIOR DOOR HANDLE SPRING MAY FRACTURE DURING NORMAL USAGE RESULTING IN INSUFFICIENT SPRING FORCE TO RETURN THE HANDLE TO THE FULLY STOWED POSITION.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.