2002 Ford Focus suspension problems

“I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts and had my engine light diagnosed. Engine codes that resulted were: B1318, B1881, C1947, B2438, B2434, P0457. The representative tested my battery and found that the voltage was slightly lower than it should be. My concern is for my safety as well as the safety of others. Do we have some manufacturer defects on this particular vehicle? Have other concerns which could be the result of vehicle wear and tear, or/and due to manufacturer defects as well. Inner tie rods need replaced as well as control arms/bushings, as reported to me by a mechanic. I have seen recall reports related to the 2002 Ford Focus in which there has been issues directly related to what I'm reporting, which is another reason I'm filing a report. Thank you. The contact wanted to add that the wipers are experiencing an electrical issue as well. When in use, the wipers…”

“VEHICLE HAS ABOUT 108,000 MILES. I DID REPLACE THE TIE RODS CONTROL ARMS AND SWAY BAR OF THE FRONT SUBFRAME. THE MECHANIC SAID THAT THE SUBFRAME IS VERY RUSTED AND THE ENGINE COULD FALL OF IF THE VEHICLE IS NOT SERVICED IMMEDIATELY. I BOUGHT THE CAR AROUND 90,000 MILES AND HAVE ALREADY REPLACED FUEL PUMP AND OTHER PARTS UNDER THE CAR.”

“AT SPEED OF 40+MPH AND UNEVEN HIGHWAY OR WHEN ENCOUNTERING A MANHOLE COVER THE REAR OF THE CAR SWAYS AND SHIMMIES LEFT TO RIGHT IN AN EXTREME MANNER. NOTICED MUCH WORSE WITH NEW TIRES THAT GRIP WELL. HAVE HAD IT INSPECTED BY A PROFESSIONAL WHO SAYS ALL VITAL PARTS LOOK OKAY. 4 WHEEL ALIGNMENT DID NOT REMEDY. I SEE REFERENCES TO A DESIGN ISSUE WITH THE UPPER CONTROL MEMBERS THAT MAKE IT IMPOSSIBLE TO REACH A CORRECT CAMBER SETTING. I DON'T TRUST MUCH ON THE INTERNET THOUGH, AND WOULD LIKE NHTSA GUIDANCE OR FURTHER INFORMATION. THANKS FOR ANY HELP YOU CAN PROVIDE, I APPRECIATE IT.”

“OK SO I'VE HAD MY FORD FOCUS FOR ABOUT 3 MONTHS NOW I FELL IN LOVE WITH THIS LITTLE THING RECENTLY GOT STRUTS CHANGED IN FRONT AND BALL JOINTS BUSHINGS AND TIRES SO I KNEW IT WOULD NEED AN ALIGNMENT SO GOT THAT DONE NOW AT SPEEDS FROM 50-60 MPH THIS CAR STARTS FISHTAILING OUT OF CONTROL I DONT HAVE ALOT OF MONEY I AM NOT WORKIN AT PRESENT SO I CANT AFFORD TO TAKE MY USED CAR TO DEALER MUCH LESS TO ANOTHER AUTO SHOP. I TRAVEL 50 -70 MILES EACH DAY TO WORK AND I'M SCARED ITS GONNA FISHTAIL ME INTO A WRECK. MILEAGE 134000 APPLKE VALLEY CALIF.”

“TL* THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING 50 TO 60 MPH, THE SUSPENSION SPRING ON THE FRONT DRIVER SIDE SNAPPED IN HALF. THE FAILURE CAUSED A SHARP POINT AND SHREDDED THE FRONT DRIVER SIDE TIRE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE TIRE AND SPRING WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 120. UPDATED 08/17/16*LJ THE CONSUMER HAS SINCE SOLD THE VEHICLE. UPDATED 08/22/16.*JB”

“TL* THE CONTACT OWNS A 2002 FORD FOCUS. WHILE THE VEHICLE WAS BEING SERVICED, THE TECHNICIAN INFORMED THE CONTACT THAT THE REAR COIL SPRING WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.”