2017 Ford Fusion Hybrid engine problems

“I was experiencing engine vibration while driving and lack of power when I pressed gas pedal. I took it to an independent garage first, and then to the dealer. Both told me there was coolant and water in the cylinders, and the dealer told me I needed a total engine replacement consisting of the long block and the head gasket. And it was going to cost me $14,000. my car only has 44,000 miles on it and Ford told me there was nothing they could do about it even though it was a known issue dating back several years.”

“2017 Ford Fusion got serviced at Ford dealership June 4, 2025. Service included, transmission flush, fuel induction service, oil change, oil filter change. About a month after service check engine light comes on upon starting the vehicle, but then goes out. A week later check engine light comes back on and would not start properly. Vehicle taken to independent mechanic and was told transmission fluid was low and also old. Vehicle taken to Ford dealership where service was done month prior. Ford dealership said cylinder misfire, coolant intrusion, and engine failure. Also transmission fluid was found to be low. Ford recommended new engine.”

“Vehicle is experiencing coolant intrusion from a crack in the engine block which is a known issue by Ford for my particular vehicle year (2017). Ford has issued a TSB/Recall for model years 2017-2019, but when I contacted Ford, I was told my car is not eligible/included in the recall because of the plant that the vehicle was manufactured at. I believe this issue should qualify for manufacturer recall as this is known issue.”

“My engine experienced coolant intrusion into cylinder #2, which caused misfiring and engine failure. This has been a known issue with this year model, but since I am just outside of the warranty mileage (69K) and my VIN doesn't have any recalls, I have been advised to purchase a replacement engine. I simply cannot afford to replace an engine in a car I am still paying a loan for. For this to be a known issue and not be recalled is a serious safety concern and has caused me to lose confidence in the manufacturer. I am currently trying to see what a shop near me would charge to replace it but I am not sure that I can afford the repair costs. I shouldn't be expected to need to replace an engine when the year model has known issues and I have taken care of any and all maintenance on the car to keep it running well. I expected to have this car for many more years, especially with the low mileage and how well I've cared for it.”

“The vehicle's engine is experiencing coolant intrusion. As such, when starting the car, white and sweet-smelling exhaust exits the exhaust pipe. Furthermore, the coolant reservoir continually runs low; however, we find no coolant on the driveway or apparently leaking from the car. That supports the mechanics assessment of a coolant intrusion. This issue, if left unaddressed, will cause the engine to run improperly, the spark plugs to become fouled, the engine to overheat, etc. I took the vehicle to a local certified mechanic. Although after looking at Ford's service bulletin, it became apparent that the vehicle is experiencing a similar issue to other 2017 models that were included in the recall. The mechanic listened to what we said and pulled up supporting documentation in the form of a Technical Service Bulletin. The check engine light just came up, within the past couple of days, well after the coolant intrusion was started. The disrepair seems to be a matter of timing. The subject has been driven quickly and cautiously.”

“What malfunctioned- Car did not give any notice that it was in engine failure for months other than under performing and upon taking it to the ford dealership was never helped with the problem they took money for an oil change and works package but failed to make sure my car was safe. My car was a safety hazard bc it gave zero warning that it was loosing power and when the engine did fail I knew something had been wrong for almost a year and felt it went ignored by Ford and was taken advantage of. The product has been confirmed by multiple mechanics that what causes it is the hose cracks and thus the engine coolant wrecks a working engine. Ford knows it’s a problem but isn’t acknowledging it and makes more money off of parts.”