2005 Ford Ranger fuel system, gasoline problems

“FIRST TIME WE WERE SHOPPING, WHEN WE STARTED THE CAR IT WOULDN'T START. WE REPLACED THE FUEL PUMP? WHEN IT HAPPEN THE NEXT TIME WE WERE DRIVING WHEN ENGINE SHUT OFF,WE WERE ON A DIRT ROAD HAD NO POWER STEERING,NO POWER BRAKES ONLY GOING 20 MPH.THE SHOP TOLD US THAT IT WAS THE FUEL SHUTOFF VALVE IN CASE OF A CRASH. I PURCHASED THE RANGER 5/30/13 FROM A FORD DEALER.OVER THE PAST YEAR THE ENGINE HAS STOPPED 8 TO 10 TIMES.WE ON A WENT TRIP LAST WEEKEND IT HAPPEN TWO TIMES ON I 84 IN IDAHO WE WERE GOING 75 MPH. I DID GET THE TRUCK OFF THE FREEWAY BUT WONDER WHAT IF WE WERE IN BOISE OR SALT LAKE WITH ALL OF THE TRAFFIC WHAT MITE HAVE HAPPEN.HAS THIS HAPPEN TO OTHER RANGERS ????? *TR”

“DRIVING ON I75 WHEN ENGINE STOPPED. I LOST ALL POWER. WAS ABLE TO COAST OFF THE ROAD AND ONTO THE SHOULDER. AFTER FIVE MINUTES, TRUCK STARTED AND DROVE HOME WITHOUT ANY FURTHER PROBLEM. CONTINUED TO HAVE SAME PROBLEM, DIDN'T MATTER WHAT SPEED I WAS DRIVING OR IF I WAS STOPPED AT A LIGHT, AND IT WOULD STOP REPEATEDLY IN ONE WEEK OR GO FOR MONTHS WITHOUT A PROBLEM. TRUCK WOULD STOP AND WOULD EVENTUALLY RESTART WITHIN A COUPLE MINUTES OR UP TO 30 MINUTES AFTER IT HAD STOPPED. I REPEATEDLY HAD TO COAST OR PUSH THIS TRUCK FROM THE ROADWAY WITHOUT ANY POWER STEERING. IN EARLY 2011, THE TRUCK STOPPED THREE TIMES IN ONE DAY. THE THIRD TIME, IT STOPPED IN FRONT OF FRIENDLY FORD, MONROE, MI. THEY KEPT IT FOR TWO WEEKS BUT IT ONLY STOPPED RUNNING FOR THEM ONE TIME AND IT REPAIRED ITSELF BEFORE THEY COULD FIND THE PROBLEM. IN MAY OF 2012, IT BEGAN STOPPING MULTIPLE TIMES IN ONE DAY. IT STOPPED AND WOULD NOT RESTART AND I HAD IT TOWED TO CREST FORD IN FLAT ROCK, MI. THEY DISCOVERED THE FUEL SHUTOFF INERTIA SWITCH HAD FAILED AND REPLACED IT AND THE PIG TAIL WIRING HARNESS. IT APPARENTLY HAD OVERHEATED FOR SOME TIME AND HAD MELTED THE WIRING HARNESS INTO THE SWITCH. I PAID…”

“DRIVING ON FREEWAY APPROXIMATELY 30 TO 40 MINUTES AT 55-70 MPH AND ENGINE SHUTS DOWN WITH NO WARNING. PULL OVER WAIT A FEW MINUTES AND ENGINE STARTS. DRIVE ANOTHER 30-40 MINUTES AND ENGINE SHUTS DOWN. PULL OVER WAIT A FEW MINUTES ENGINE STARTS. *TR”

“DRIVING ON FREEWAY APPROXIMATELY 30 TO 40 MINUTES AT 55-70MPH AND ENGINE SHUTS DOWN WITH NO WARNING. PULL OVER WAIT A FEW MINUTES AND ENGINE STARTS. DRIVE ANOTHER 30 TO 40 MINUTES AND ENGINE SHUTS DOWN. PULL OVER WAIT A FEW MINUTES - ENGINE STARTS. WENT TO PUT GAS IN TRUCK AND ENGINE WOULD NOT START. RESET FUEL INERTIA/SHUT DOWN SWITCH AND TRUCK STARTED. *TR”

“TL* THE CONTACT OWNS A 2005 FORD RANGER EDGE. THE CONTACT WAS DRIVING 35 MPH WHEN THE VEHICLE STALLED. THE CONTACT STATED THAT THE STALLING WAS CAUSED BY THE RESET BUTTON BECOMING TOO HOT AND STOPPING THE FUEL FLOW TO THE ENGINE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL PUMP WAS FAULTY. THE DEALER REPLACED THE FUEL PUMP BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND THE DEALER REPLACED THE SECOND FUEL PUMP BUT TO NO AVAIL. THE FAILURE PERSISTED AND THERE WERE NO FURTHER REPAIRS. THE FAILURE MILEAGE WAS 77,000.”

“TWO TIMES IN 2 DAYS I WAS DRIVING WHEN THE VEHICLE SUDDENLY STALLED/SHUTOFF. FORTUNATELY BOTH TIMES I WAS ABLE TO PULL OVER OUT OF TRAFFIC. IT FELT LIKE MY PEDAL WENT DEAD, I LOST MY POWER STEERING AS WELL. SINCE I WAS ABLE TO CONNECT TO THE INTERNET THROUGH MY PHONE I WAS ABLE TO SEARCH "FORD RANGER SUDDENLY DIES WHILE DRIVING." AN OVERWHELMING AMOUNT OF RESULTS INDICATED TO RESET MY INERTIA FUEL SHUTOFF SWITCH. I FOUND IT, RESET IT AND THE TRUCK STARTED AGAIN. AFTER THE SECOND TIME THIS HAPPENED I RESEARCHED FORD RANGER RECALLS, ONLY TO FIND THIS WAS NOT ONE OF THEM. I FEEL VERY APPREHENSIVE ABOUT DRIVING MY TRUCK, NOT KNOWING WHY IT SUDDENLY DECIDES TO TRIP THE FUEL SHUTOFF SWITCH. THIS IS EXTREMELY DANGEROUS AND IT NEEDS TO BE RECALLED.”