2019 Ford Ranger engine problems

“The cooling fan clutch control wire is supported by a "wire support hose" between the engine block and the fan clutch. the cooling fan clutch control freely rotates on a raceway on the drive shaft. The purpose of the support hose is to prevent the fan clutch control from freely rotating, but allows the control a limited range of movement as the drive shaft changes speed with engine RPM. The idea is that this hose prevents undue stress on the control wire. Hose is normally a consumable part that may need replaced with age, heat, etc. The hose is not sold as a replacement part and can only be obtained by purchasing a new fan clutch. When the hose fails, the control wraps around the drive shaft causing damage to the fan clutch control and wiring requiring replacement. The circuit on which the fan clutch control sits is integrated with no less than 6 other critical vehicle systems including oil pressure. When the incident occurs, all these systems generate errors that put the vehicle into limp mode until repair can be made. The fan clutch control wiring support hose should be a bracket with a different mechanical linkage solution to support wire while allowing the…”

“I was driving the vehicle, when I started to fell a " Shuddering " sensation on acceleration. I let off the gas pedal and the Shuddering went away. A few miles down the road the check engine light came on and was flashing. I immediately pulled and shut the vehicle off. After sitting for 10 minutes I restarted the vehicle and the check engine light was no longer on, but the " Shuddering " sensation was still present. I took it to Dupratt Ford in Auburn,Ca. and they diagnosed it as a Cylinder 1 mis-fire. Upon further inspection they found water in the Cylinder 1 spark plug well. After doing some research I found out the Ford issued TSB 23-2011for this exact issue, but did not order a recall to fix the faulty windshield cowl which is the problem. I found thousands of complaints and numerous Ranger owners who have had the exact same issue and had to pay out of pocket to get the issue and damaged fixed. Meanwhile Ford knew about the issue and did absolutely nothing, did not even alert the owners of the issue. I was lucky and did not have to replace the cylinder head, but others have not been so lucky. I had to pay over $1800 to have the mis-fire issue fixed and had…”

“The brakes failed within hours of owning the Certified, WARRANTIED VEHICLE. ALMOST had an accident. Within <5 weeks of owning this warrantied certified vehicle, was stranded on Rine Ridge Indian Reservation and on the highway. Engine jerk so bad feels like I a derby car. Then just stalls. The dont comply with their own 172 point certified inspection. They claim two keys for specified vehicle. They gave me two 1 starts the vehicle the other errors no key in ignition when you insert into ignition. NOW I have to pay bills to get a warrantied certified vehicle repaired plus loaner car because Ford McKie k owing sold an Unsafe vehicle under deceptive pretense. Multiple engine and brake failures which was supposedly certified inspected.”

“On friday, march 27th, 2026. My 2019 ford ranger began shaking before the engine stalled. Warning lights for an engine check came on and my vehicle would not go above 20 mph after restarting. When pressing on the accelerator the engine would rev but the vehicle would not accelerate. I took the 2019 ford Ranger to a local Ford Dealership service center and they diagnosed the following problems (listed in full below).The cooling fan was at issue and multiple wires connecting my engine to the rest of the vehicle were melted off. The ford dealership said that this issue is extremely rare and they have never seen it before. After receiving this information from the dealership I discovered that the 2019 ford ranger has had several recalls with the areas at issue in my vehicle. The recalls are under number 25V685000 (Engine block heater), and 20V137000 (Fan). Here is the full diagnosis from the ford dealership attached below: VERIFIED CUSTOMER CONCERN FOUND VEHICLE TO HAVE CEL LIGHT ON, AND MULTIPLE WARNING LIGHTS PERFORMED DIAG AND FOUND SHORT CIRCUIT PRESENT. TRACED SHORT FOUND COOLING FAN CLUTCH FAILED AND HARNESS RUBBING IN CLUCH ASSEMBLY FOR COOLING FAN The fan…”

“My truck experienced a P0302 misfire on the freeway, which caused it to shake immediately and made it very difficult to drive. I had it towed to the dealership, and they told me there was water in the spark‑plug wells, which was surprising since I live in Las Vegas, NV, where it rarely rains. My spark plugs were rusted as well as the cylinder head. After looking into it online, I discovered that Ford issued TSB‑23‑2011 for the Ford Ranger due to a windshield cowl leak that allows water to drip directly onto the engine. Their proposed fix is to install an engine cover, but that clearly doesn’t solve the issue since my truck already has the engine cover installed. Now I’m stuck paying for repairs caused by a design flaw that Ford never properly addressed.”

“Truck looses gear when pulling into traffic. It will shift out of gear and only allow coasting. At speeds of 40 MPH and higher it will down shift causing dramatic reduced speed with no brake warning to other drivers behind. It will also randomly loose power. It will have delayed shifts squealing tires upon shifting and excessive jerking that is uncontrollable.”