2003 Ford Taurus suspension problems

“ON OCTOBER 23 2019, I RETAINED MAVIS DISCOUNT TIRE TO INSPECT MY NEW YORK STATE REGISTERED 2003 FORD TAURUS. MAVIS DISCOUNT TIRE PASSED THE VEHICLE, DETERMINING THE VEHICLES CONDITION COMPLIED WITH NY STATE SAFETY STANDARD OF ROADWORTHINESS. 12/12/2019, AFTER REPAIRING THE TRANSMISSION AT GORILLA AUTO WORKS, I WAS INFORMED OF A SERIOUS STRUCTURAL SITUATION, CONTROL ARM ASSEMBLY "SEVERELY DETERIORATED". ON JANUARY 20TH 2020, I AGAIN REFERRED THE VEHICLE TO CASKINETE FORD CARTHAGE NEW YORK FOR FURTHER EVALUATION, AT FORD MOTOR COMPANY STANDARDS, AS WAS INFORMED, THAT THE CONTROL ARM ASSEMBLY WAS NOT REPAIRABLE, AT THE PRESENT CONDITION, DID NOT MEET NEW YORK STATE OR FEDERAL SAFETY STANDARDS, CONTRARY TO THE ORIGINAL STATUS, AND INSPECTION , ISSUED 10/23/2019 MAVIS DISCOUNT TIRE ARSENAL ST. WATERTOWN NEW YORK. FURTHER EVALUATIONS, STUDY REVEALED, THAT FAILURE OF THIS CONDITION, UNDERWAY, AT US INTERSTATE AVERAGE SPEED OF TRAFFIC, POTENTIALLY CATASTROPHIC INCIDENT WOULD RESULT, EMINENT RISK OF LOSS OF LIFE. PER US AGENCY STANDARDS, I HAVE MADE ALL REASONABLE EFFORTS TO RESOLVE THIS COMPLAINT WITH RELEVANT STATE AGENCIES, DMV. ETC. ADDITIONAL EFFORTS INCLUDED…”

“I WAS BACKING OUT OF MY PARKING SPACE AT WORK AND I HEARD A LOUD NOISE AND THEN FTHE AIR WWNT OUT OF MY TIRE ON THE FRONT DRIVER SIDE REAL. ONCE THE TIRE WAS REMOVED IT REVEALED A LARGE GASH IN THE SIDE WALL OF THE TIRE AS A RESULT BROKEN COIL.”

“DRIVER'S SIDE FRONT COIL SPRING BROKE AND PUNCTURED TIRE. VEHICLE WAS THANKFULLY PARKED WHEN THIS HAPPENED. THERE WAS A RECALL NO. 04V332000, FOR 1999-2001 MODELS - CURIOUS WHY IT STOPPED THERE? MULTIPLE ONLINE FORUMS INDICATE THIS ISSUE CONTINUED PAST 2001. PHOTOS AVAILABLE IF NEEDED.”

“A STRANGE GRINDING NOISE WAS COMING FROM THE PASSENGER FRONT TIRE AREA WHICH WAS VERY NOTICABLE TRYING TO BACK OUT OF DRIVEWAY, SO PULLED BACK IN AND LOOKED TO SEE WHAT MIGHT BE WRONG. I NOTICED A BURNING RUBBER SMELL AND THAT THE WHEEL CLEARANCE WAS SIGNIFICANTLY LESS ON PASSENGER VERSE DRIVER FRONT TIRE. DROVE UP ONTO RAMPS TO LOOK FROM BENEATH AND COULD CLEARLY SEE THE END OF THE COIL POKING INTO THE INSIDE EDGE OF THE TIRE WITH A WORN MARK ALL THE WAY AROUND WHERE IT WAS PUSHING INTO THE RUBBER. AFTER CAREFULLY BACKING OFF RAMPS, IT WAS JACKED UP AND PLACED ON JACK STANDS, AT WHICH TIME IT WAS CLEARLY VISIBLE THE COIL SPRING WAS SNAPPED IN TWO. IT IS A MIRACLE THIS WAS FOUND BEFORE MY SISTER DROVE 70MPH ON THE HIGHWAY SHE WAS ABOUT TO. THIS WOULD'VE CERTAINLY CAUSED A BLOWOUT AND POTENTIALLY A FIRE, AND AT THOSE SPEEDS COULD'VE CERTAINLY BEEN DEADLY.”

“KEEP SHUTTING OFF RANDOMLY WHILE DURING IN THE CITY SITTING AT A TRAFFIC STOP. DOESN'T START ALL THE TIME. THERE'S RATTLING AND CLUNKING NOISE UNDER THE FRONT OF THE VEHICLE”

“I REGRET TO REPORT THAT MY DAUGHTER-IN-LAW EXPERIENCED A CATASTROPHIC FAILURE OF 3 COIL SPRING ASSEMBLIES AND A SUBSEQUENT FRONT DRIVER SIDE TIRE FAILURE DUE TO A PUNCTURE A FEW MONTHS AGO WHILE WAS DRIVING AT A LOW RATE OF SPEED IN HER PARENTS' NEIGHBORHOOD IN WINONA. FORTUNATELY NO ONE WAS INJURED AND SHE WAS ABLE TO PULL THE CAR INTO THE DRIVEWAY. WE ARE THANKFUL SHE WASN'T DRIVING AT HIGHWAY SPEEDS ON THE INTERSTATE. THE CORROSION OF THE COIL SPRINGS HAS BEEN A KNOWN DESIGN PROBLEM FOR YEARS. I HAVE DONE SOME RESEARCH AND FOUND THAT THE 2003 MODEL YEAR IS NOT ON A RECALL AT THIS TIME. HOWEVER EARLIER MODEL YEARS OF TAURUS HAVE BEEN RECALLED FOR THIS SAME ISSUE IN THE PAST, SO CORROSION OF THE COILS IS A KNOWN PROBLEM. THE CAR IS A 2003 FORD TAURUS, 73,663 ACTUAL MILES, WELL-MAINTAINED, NO VISIBLE EXTERNAL RUST, GARAGED NIGHTLY. THIS CAR WAS PURCHASED FROM THE FORD DEALERSHIP IN ROCHESTER, MINNESOTA.”