1999 GMC Sierra 1500 service brakes problems

“ABS Brakes cut out leaving you with little to no brakes. No warning light appears. This continues on and off over time. Then that ABS warning light came on. When the warning light was on, brakes worked just not ABS. Light would go out and back to the original issue. Took it in to dealership when the light remained on. They reset the light and told me every thing was fine. And charged me $$$. ABS Brake warning light can right back on. Had the manager drive it. Told me it was fine, brakes worked well. The ABS warning would go in and out. Removed the ABS fuse, so I could depend on being able to stop, without having to worry about the ABS cutting in and out for a few years. Watched for recalls, nothing appeared. Noticed on blogs, others were having the same issue. Took it to a great mechanic! Who verified there were no leaks in the brake lines, replaced one line that had been known to have issues on this type of truck and verified there were no air bubbles on the lines. Still same issue, then replaced the computer system for the ABS. No codes ever came up on the computer system that I can recall. Had more issues with the ABS. Would go to stop, (generally on a hill)…”

“I WAS DRIVING HOME FROM WORK ON 421 IN EMINENCE, KY. I PUSHED THE BRAKE PEDAL & I HAD NO BRAKES RIGHT IN FRONT OF HARRY HILL PARK. GM & I ARE VERY LUCKY THAT NO ONE WAS KILLED YESTERDAY. THE BRAKE LINE CORRODED & LEAKED THE BRAKE FLUID, SO WHEN I PUSHED THE PEDAL, IT WENT RIGHT TO THE FLOOR. THE VEHICLE IS PRETTY CLEAN & AFTER CHECKING MANY BLOGS & YOUTUBE VIDEOS THIS IS A VERY COMMON PROBLEM ON GM TRUCKS. I CHECKED THE RECALLS ON THIS TRUCK & THE TAILGATE CABLE IS RECALLED FOR BREAKING UNDER LOAD DUE TO CORROSION; THIS COULD INJURE SOMEBODY, BUT NOT AS VITAL COMPARED TO THE BRAKING SYSTEM AS SOMEONE COULD DIE IN A HORRIBLE INCIDENT. I WOULD GREATLY APPRECIATE YOUR ATTENTION TO THIS SERIOUS MATTER. THANK YOU”

“WHILE OPERATING THE VEHICLE AT APPROXIMATELY 45 MPH, I WAS APPROACHING AN INTERSECTION WHEN I APPLIED THE BRAKES TO SLOW THE VEHICLE. ONE OF THE REAR BRAKE LINES BURSTED CAUSING ME TO HAVE TO ABRUPTLY PUMP THE BRAKE PEDAL TO STOP THE VEHICLE. VERY DANGEROUS SITUATION AS A MARKED SHERIFF'S VEHICLE WITH ITS EMERGENCY LIGHTS AND SIREN ACTIVATED WAS TRAVELING AT A HIGH RATE OF SPEED ON THE INTERSECTING HIGHWAY THAT I WAS APPROACHING. THIS IS A KNOWN AND PREVALENT PROBLEM THAT EXISTS WITH GM TRUCKS AND GM IS WELL AWARE OF THE ISSUE BUT DENIES FAULTY PARTS.”

“TL* THE CONTACT OWNS A 1999 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOOR WHEN THE PEDAL WAS DEPRESSED. THE VEHICLE CAME TO A STOP AND THE CONTACT NOTICED FLUID LEAKING UNDERNEATH THE VEHICLE. THE CONTACT HAD THE VEHICLE TOWED TO QUALITY CHEVROLET (1292 ROUTE 9 SOUTH OLD BRIDGE, NJ, 08857; 732-316-2600) WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE EXPLODED AND AREAS OF THE BRAKING SYSTEM WERE RUSTED, WHICH CAUSED THE BRAKING SYSTEM TO FAIL. THE VEHICLE'S BRAKING SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 216,000.”

“DURING NORMAL STRAIGHT STOP FROM 50 MPH ON RURAL COUNTY ROAD, INTERSECTION WITH 70 MPH CROSSING 4-LANE DIVIDED STATE HIGHWAY, PEDAL WENT TO FLOOR AND BRAKING ABILITY WAS MINIMAL. EMERGENCY BRAKE NEEDED TO COMPLETE THE STOP BEFORE ENTERING CROSSING HIGH-SPEED TRAFFIC. UPON INSPECTION, DISCOVERED BRAKE LINE RUPTURED DUE TO RUST WITH MASSIVE INSTANTANEOUS FLUID LOSS.”

“TL* THE CONTACT OWNS A 1999 GMC SIERRA 1500. WHILE STOPPING THE VEHICLE, THE CONTACT HEARD AN ABNORMAL CLUNKING NOISE. THE PARKING BRAKE WAS ENGAGED, BUT IT FAILED TO RESPOND AND CAUSED THE VEHICLE TO MOVE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 204,206.”