2025 GMC Sierra engine problems

“This is a follow up to my recent safety concern on my 2025 GMC Sierra 1500 with the 6.2 engine. Dropped off my vehicle to our GMC service dealer on 10/22/2026 - Oil change and 15K mile check up was getting close. Mileage at drop off was 14,278 and the engine was still making sounds/noise and getting louder. Asked the service advisor to check for metal in the oil or filter. Based on their service review and advisors response, metal was found in the oil filter and engine is ticking. Service department sent information to GM rep for further actions needed. Dealer rep stated that I need a new engine due to this new found issue. Waiting for response from a GM representative at this time. Truck is in my garage at home. I remain very concerned about driving this vehicle at this time. Just called the dealership as I have not heard of any follow up yet. Call went to voice mail of my service advisor. 6.2 Engine is ticking and metal has been found in the filter. Please add this to my original concern on this VIN #.”

“The contact owns a 2025 GMC Sierra 1500. The contact stated that while her husband was driving 10 MPH, the vehicle lost power. The driver turned off the vehicle and attempted to restart the vehicle; however, the vehicle failed to respond. No warning light was illuminated. A dealer was contacted. The vehicle was towed to the dealer where it was diagnosed and determined that the engine needed to be replaced. The engine was replaced and the vehicle was repaired. The contact stated that the engine was replaced twice. The manufacture was notified of the failure and opened a case. The approximate failure mileage was 64,000.”

“The engine locked up and stalled out while driving. GM replaced engine but still experiencing issues. Dealer has admitted that they will likely recall my model year since it is an ongoing and same issues as recalled trucks. I have a vehicle I am not confident in nor safe it since it stalled while driving.”

“Engine lost power and is smoking profusely. An independent service center told us there is a problem with one or more of the cylinders. No, there were no warning lamps. It's here, but we can't drive it.”

“In April 2025, we purchased a new GMC Denali Sierra 1500 Ultimate pickup truck. Concerns – Many of these comments appear in the Dealer Service Reports 1st Service Visit 10/17/25 At our first oil change and scheduled maintenance (10/17/25) with mileage of 5403 miles, during the drop-off I informed the GM Service Advisor of a clicking sound from the engine which I thought might be a fan belt. When I picked up the truck from Service, the Service Adviser informed me that upon startup, a “clatter” type noise was heard, “reminiscent of bad lifters.” The Service Adviser reported that during the mechanic’s test drive, the “clicking noise would get louder with engine speed.” No trouble codes were found after being checked by the MDI. They checked for misfires and a few misfires were found but “not often. At “idle” during this service call, the Left Engine Bank had a “good click/metallic tap to it.” “When the idle was raised, the Right Bank would get loud and had a loud tapping sound.” The oil change did not show any visible metal particles. The GM Service Department recommended a “complete tear-down of the engine for further inspection,” tentatively scheduled in a few…”

“Vehicle lost power. Pulled into parking lot steering wheel locked. Tried to restart truck nothing happened. Took to dealer they said motor needed to be replaced and it would take 4 to 6 weeks.”