2000 Hyundai Elantra engine and engine cooling problems

“FAX FROM CONGRESSMAN DENT ON BEHALF OF CONSTITUENT WHO IS REQUESTING ASSISTANCE IN REGISTERING A COMPLAINT AGAINST HYUNDAI. *NJ THE CHECK ENGINE LIGHT ILLUMINATED AND A LOUD NOISE WAS HEARD. THE EXHAUST MANIFOLD WAS REPLACED DUE TO IT BEING CRACKED. (THE CONSUMER WHO WROTE IN, WORKS FOR THE DEALERSHIP THAT SOLD THE CONSUMER THE VEHICLE. THE DEALERSHIP DIDN'T CHARGE THE CONSUMER FOR THE REPAIRS, HOWEVER THE DEALERSHIP IS REQUESTING REIMBURSEMENT FROM HYUNDAI) *JB”

“RECALL NOTICE FOR 2000 HYUNDAI ELANTRA. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR POSSIBLE CRACKS IN THE MANIFOLD. IT WAS INSPECTED AND THE REPAIRS WERE COMPLETED. *NJ THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A REPAIR SHOP AND THE CONSUMER WAS INFORMED THE MANIFOLD WAS CRACKED AND HAD TO BE REPLACED ALONG WITH THE ATTACHED CATALYTIC CONVERTER. *JB”

“TL*THE CONTACT OWNS A 2000 HYUNDAI ELANTRA. THE CONTACT'S VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 00V259001 (ELECTRICAL SYSTEM:WIRING). THE CONTACT WAS UNAWARE OF THE REPAIR. SEVERAL MONTHS AFTER THE REPAIR WAS MADE, THE VEHICLE LOST POWER WHILE DRIVING VARIOUS SPEEDS AND CAUSED HIM TO DECELERATE. THE VEHICLE ALSO LOST POWER STEERING ABILITY, AND EVENTUALLY THE VEHICLE WOULD STALL. THE CONTACT HAS TO PLACE THE VEHICLE INTO NEUTRAL AND THEN RESTART IT IN ORDER FOR IT TO BE FUNCTIONAL. HE TOOK THE VEHICLE TO THE DEALER ON NUMEROUS OCCASIONS, BUT THE FAILURE COULD NOT BE DUPLICATED. OVER THE PAST SEVERAL YEARS, THE DEALER REPEATEDLY REPLACED THE CRANKSHAFT POSITION SENSORS AND POWER RELAY. SECONDLY, BECAUSE THE VEHICLE WAS PREVIOUSLY REPAIRED ACCORDING TO THE RECALL, THE DEALER WOULD NOT ASSUME FINANCIAL RESPONSIBILITY FOR THE REPAIR. THE CONTACT CALLED THE MANUFACTURER AND IS WAITING FOR THEIR RESPONSE. AS OF JULY 18, 2008, THE CONTACT HAS NOT RECEIVED ANY ASSISTANCE. THE FAILURE MILEAGE WAS 10,000 AND CURRENT MILEAGE WAS 108,000.”

“I THOUGHT MY MUFFLER HAD A HOLE IN IT SO I TOOK TO A SHOP AND THEY TOLD ME THERE WAS NOTHING WRONG WITH MY MUFFLER. TO ANOTHER SHOP AND TOLD I HAVE A CRACKED MANIFOLD. I THINK IT'S ABSURD THAT A 2000 MODEL CAR COULD GO THROUGH 2 MANILFOLDS IN 7 1/2 YEARS. WAS AT THE DEALERSHIP ON 10/09/03 REPORTING THE EXHAUST SYSTEM WAS NOISY. WAS TOLD IT WAS NOT MUFFLER BUT WAS A CRACKED MANIFOLD. LUCKILY IT WAS REPAIRED UNDER WARRANTY. THAT WAS LESS THAN 5 YEARS AGO. SOUNDS LIKE A BIG PROBLEM TO ME. I CAN UNDERSTAND ONE MANIFOLD GETTING CRACKED...BUT TWO IN LESS THAN 4 1/2 YEARS. THIS CAR IS DRIVEN LESS THAN SIX MILES ROUND TRIP TO WORK A DAY. IT'S NOT LIKE I'M OUT TEARING UP THE TOWN ALL THE TIME IN THE CAR. *TR”

“2000 HYUNDAI ELANTRA - NEW------------7/05 W/ 17,923 MILEAGE ON THE CAR. I NEEDED TO REPLACE THE MOTOR ON THE PASS. FRONT WINDOW & BOTH BACK WINDOWS. IT IS NOW 12/07 AND I NEED TO REPLACE THE SAME MOTORS IN ALL 3 WINDOWS , MY CAR NOW HAS 29,420 MILEAGE ON THE CAR. THE WINDOW THAT I WOULD USE THE MOST IS THE DRIVERS FRONT , IS JUST FINE. *TR”

“DT*: THE CONTACT STATED WHILE DRIVING 15 MPH, THE ENGINE HESITATED, THEN STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THAT THE PROBLEM WAS WITH THE MASS AIR FLOW SENSOR WHICH WOULD NEED TO BE REPLACED. HOWEVER, THE REPLACEMENT PARTS NEEDED TO BE ORDERED. THE MANUFACTURER WAS CONTACTED WHO DETERMINED THERE WAS A RECALL # 00V259001 REGARDING ELECTRICAL SYSTEM:WIRING BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.”