2015 Hyundai Genesis electrical system problems

“The contact owns a 2015 Hyundai Genesis. The contact stated that while his niece was attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to a local dealer, where it was diagnosed with an internal leak causing the starter to burn and the wiring harness to melt. The contact stated that the starter and wiring harness needed to be replaced. The contact stated that the local dealer denied the repair under NHTSA Campaign Number: 24V107000 (Electrical System); unless other repairs were first performed. The manufacturer was made aware of the failure. The failure mileage was approximately 74,887.”

“Starter wiring burned and caused a small, localized fire in the engine compartment of the vehicle. Replacement of the starter assembly along with related engine wiring harness is necessary for vehicle operation. After mechanic review, it was determined the vehicle will catch fire upon attempt to start the vehicle. The vehicle was parked near our home when the internal burning and subsequent small fire started. The problem was reported to our nearest Hyundai dealership and the car was evaluated by the dealership to confirm the above. The car was inspected by Progressive insurance as well at the dealership and it was determined it was not included in TSB 24-01-057H recall for this VIN for the 2015 Hyundai Genesis. For this specific issue, there was zero indication this was a possibility.”

“UNKNOWN, The car lose electricity, shutting down by itself, when I press start engine, or when I shut down engine, recently car shuts off while I drive it on highway, it didn't start until I jump start it, also it shows lights of ABS, and brakes auto hold, cruise control not working.”

“I took my car in to Tomball Hyundai due to intermittent failure of the headlight switch and the wiper switch when both of these features are set to the ‘Auto’ setting. These are very intermittent issues, but as luck would have it, it was sprinkling on my drive to the dealership on [XXX] and I was able to capture the wiper issue via video on my phone which I shared with the service advisor. Then, fortunately, 2 days later, the service technician was able to verify the intermittent headlight failure. I was aware of a TSB (TXXH) which is meant to address this problem, however, Hyundai issued a superseded TSB a few months after the original, in which they deleted the wiper switch from the service. The 2015 Genesis multifunction switch is sold as a single integrated unit (P/N 93400-3M031), but Hyundai’s TSB 20-BE-009H-1 mandates a "hack" repair that leaves the failing wiper switch in place. It is my assertion that when Hyundai settled a class action lawsuit regarding this switch, they agreed to extend the warranty on the entirety of the Multifunction Switch Assembly (NOT just the Headlight portion of the switch) for 15 years and Unlimited mileage. The Hyundai…”

“While driving approximately 35–40 mph, the steering wheel locked unexpectedly. My [XXX] child was in the vehicle at the time. I was nearly unable to control the vehicle, creating a serious risk of a crash or fatal injury. The vehicle has a long history of electrical problems including repeated battery failures and a prior transmission replacement. Due to the steering failure, the vehicle is unsafe to operate and has not been driven since the incident. No warning lights were observed prior to the steering failure.”

“My car has previously been reported for having issues with electrical problems that I have had to fight the manufacturer to get repaired unsuccessfully.I am constantly experiencing and smelling burning in my dash when I crank the car. Car is no longer under warranty, so therefore, I cannot afford to continue to go in and report the same problem over and over again.My turn signal bulbs are constantly blowing, and I'm having to replace them at a rate that is not normal.I'm sure this is all related.”