2023 Hyundai Palisade power train problems

“I was driving and stopped at the tunnel for traffic. My car shut off and wouldn’t turn back on. It seemed to have overheated. After about ten minutes, it started again. I was told it was told the oil pump controller affecting the stop and go on my car. Priority Hyundaii in [XXX] didn’t didn’t have the part to repair it. Now they are refusing to repair it.”

“I have had 4 appointments for my 2023 Hyundai Palisade to have the recall on the seat belt buckles addressed. Each time, I am told by the dealership that Hyundai hasn't sent the part yet. I was told that Hyundai is only sending 10-15 parts at a time. There are a lot of these vehicles on the road, and at this rate, my car is never going to be fixed. There is also an open warranty for the 3rd row ejection mitigation that there is no fix for yet. I was told not to use the third row, which is not really possible and is part of why I bought a car with 3 rows of seats. I feel uncomfortable driving my car as well as having passengers in the first and second row, as I feel the seat belt might not hold if there was an accident. My safety and the safety of my passengers is potentially being compromised. I feel that we received the seat belt recall 9 months ago and that is plenty of time to address this problem. I am requesting for the NTSB to get involved and require Hyundai to provide a loaner car (of the exact same size and capacity) until my Palisade can be reapired. I was also told at an additional appointment that the rear shocks that leak are also waiting for…”

“Two simultaenous problems happened: 1) loud clunking/thudding during low-speed turn. 2) Clunking/knocking/rattling noise from suspensions when going through uneven grounds. This both things happened before 20,000 miles. Had AWD coupling and rear differential unit replaced under warranty regarding problem 1). Had rear shocks replaced under warranty regarding problem 2). Found there has bben TSB issued related to 2), for older models, TSB 25-SS-004H but not for this year of models. Those two exact problems started again at about 40,000 miles. Had vehicle checked at 50,500 miles recently. Regarding problem 1), the dearship found issue with AWD coupling, stating faulty parts, drive shaft seal was 1/8" off and materials are fused. Replaced AWE coupling, and ECU program update. After program update, I do not see the power distribution monitor anymore from my dash. The program update should turned it off for some reason that I do not know. I have no clue that AWD module is working normal as I cannot see the power distribution action anymore. Regarding problem 2), they replaced both rear shocks again. The problem went away for now. This vehicle has been only 50,000…”

“Our Hyundai has a powertrain problem that is intermittent and random, and manifests itself in a couple of ways: 1) It drops out of gear while you are driving; there is no forward propulsion at all; the engine will rev when you press the gas, but no forward movement at all. You have to coast to a stop (or panic stop if the traffic allows), put it in reverse, drive backwards, then the transmission will “chunk” back into gear, then you can put it back in drive and continue forward again. This is life-threatening on a busy road or highway. Traffic has to flow around you like water around a rock in a stream while you try to use what’s left of your forward momentum to pull to the side of the road. Absolutely terrifying!!! The dash has also gone completely blank during some of these episodes. Nothing changes the situation: pressing “D”, shifting the paddles, nothing gets the vehicle back in gear. We have video taped these events twice, and provided those videos to our Hyundai Service Center, and to the Hyundai National Consumer Affairs team. They claim that they can’t reproduce it on demand, so they have done NOTHING. We are scared to drive the car. 2) As you start…”

“The steering wheel clunks and locks when turning at low speeds or when ISG turns the car back on. At times, it is a hard enough jerk to pull it out of my hands. It was taken to the dealership multiple times. The coupler was replaced, but it still jerked the steering wheel. The dealership in Utah could not replicate the sound, even though it occurs multiple times a day at this point. Loss of the ability to steer after sitting at a light poses a huge safety issue between not being able to immediately navigate upon accelerating or when turning left at an intersection.”

“2023 HYUNDAI PALISADE VIN [XXX] Vehicle rear shock absorbers failed. Steering and drivability adversely impacted. Many many many complaints online document these defective parts and Hyundai's failure to resolve problems and supply properly functioning parts. Hyundai customer service is useless and claims no information on replacement part availability or time. Now that Hyundai has their newest problem of killing babies in their defective third row seats, I would have thought Hyundai would resolve outstanding issues. NHTSA needs to intervene now.”